Table Of Contents; Important Safety Instructions - Wayne-Dalton IDrive 3651-372 Installation Instructions And Owner's Manual

Table of Contents

Package Contents ............................................................................... I.
Pre-Installation Inspection . .................................................................. II-III.
Tools Needed ...................................................................................... III.
Important Safety Instructions .............................................................. IV.
Torsion idrive Installation . .................................................................... 1-16.
Pre-Operation Installation . ................................................................... 17-25.
Operation ............................................................................................ 26-31.
Maintenance ....................................................................................... 31.
Troubleshooting . .................................................................................. 32-33.
Warranty ............................................................................................. 33.
Customer Service Number .................................................................. 34.
You can reach us Toll Free at 1-888-827-3667 for Consumer Assistance or online at www.wayne-dalton.com
Please Do Not Return This Product To The Store Call Us Directly! Our Trained Technicians Will Answer Your Questions and/or Ship Any Parts You May Need
WARNING
INSTALLATION CAN LEAD TO
SEVERE OR FATAL INJURY.
FOLLOW THESE INSTRUCTIONS
CAREFULLY.
IMPORTANT SAFETY
INSTRUCTIONS
1. READ AND FOLLOW ALL INSTALLATION INSTRUCTIONS.
2. D o not connect the Opener to electrical power until
instructed to do so.
3. I nstall the Entrapment Warning Label next to the
Wall Station in a prominent location. Install the Emergency
Disconnect Label next to the Emergency Disconnect.
4. R emove all ropes and remove or make inoperative in the
unlocked position, all locks connected to the garage door
before installing the Opener.
5. D o not wear rings, watches or loose clothing when installing
or servicing a garage door system.
6. I t is important that you install all the components supplied
with the idrive Opener, i.e., Wall Stations, Safety Sensors, etc.
Use of parts not supplied by Wayne-Dalton Corp. may cause
the Opener to malfunction and create unsafe conditions.
7. W ear safety glasses for eye protection when installing or
servicing the Opener or door.
8. I nstall Opener on a properly balanced and operating garage
door. Have a qualified service person make adjustments/
repairs to cables, spring assemblies, and other hardware
before installing the Opener. An improperly balanced door
could cause severe injury.
9. W here possible, install the Opener seven feet or more above
the floor. Mount the Emergency Disconnect six feet above
the floor.
10. L ocate the Wall Station: (a) within sight of door, (b) at a
minimum height of five feet, so small children cannot reach it,
and (c) away from all moving parts of the door.
11. A fter installing the Opener, the door MUST reverse when it
contacts a 1- 1/2" high object (or 2 x 4 board laid flat) on
the floor. The door MUST also reverse when a 6" high object is
placed on the floor in line with safety sensors.
12. I nstallation and wiring must comply with local building and
electrical codes. Connect the Power Cord to a properly
grounded outlet. Do not remove the ground pin from
Power Cord.
After installation is complete, fasten this
manual near garage door. Perform Monthly
obstruction test and maintenance as
recommended. See pages 23 and 31.
INCORRECT
IV