Rear Door Weatherstrip Installation; Rear Door Window Regulator Removal And Installation; Rear Door Window Glass Removal; Door Opening Weatherstrip - Jeep 200 Cherokee Service Manual

XJ
REMOVAL AND INSTALLATION (Continued)
Fig. 55 Door Opening Weatherstrip
1 – FRONT DOOR SEAL
2 – A PILLAR
3 – SECONDARY DOOR SEAL
4 – FRONT DOOR SEAL
5 – REAR DOOR SEAL
6 – ENDS MEET AT CENTERLINE
7 – A PILLAR
INSTALLATION
(1) When installing a door opening weatherstrip
seal, start at the door sill center line.
(2) Move upward and around edge of door opening.
Seat seal on flange.
(3) Move upward and around the perimeter of the
door opening and seat the weatherstrip on the flange
(Fig. 56).
(4) Install upper door opening trim.
(5) Install inner scuff plate.
(6) Install B-pillar lower trim panel.
(7) Install B-pillar upper trim panel.
REAR DOOR WINDOW REGULATOR
REMOVAL
(1) Remove the door trim panel.
(2) Remove the waterdam.
(3) Remove the bolt attaching the window glass to
the regulator and support the glass (Fig. 57).
(4) Remove the lower bolts attaching the regulator
to the inner door panel (Fig. 58).
(5) Remove the nuts attaching the regulator motor
to the inner door panel, if equipped.
(6) Loosen the upper bolt that attaches the regula-
tor to the inner door panel.
Fig. 56 Door Opening Weatherstrip
1 – VENT HOLES
2 – VENT HOLES
3 – FINISH
4 – START
5 – FINISH
6 – START
7 – B-PILLAR
8 – SEAL
9 – REAR DOOR WEATHERSTRIP SEAL
10 – FRONT DOOR WEATHERSTRIP SEAL
11 – FLANGE
12 – SEAL
13 – FLANGE
(7) Disconnect the wire harness connector from the
regulator drive motor, if equipped.
(8) Remove the regulator and drive motor, if
equipped.
INSTALLATION
(1) Position window regulator and, if equipped,
drive motor within the door panels.
(2) Install the fasteners attaching the regulator to
the door inner panel.
(3) Connect the regulator wire harness connector.
(4) Position the window glass at the regulator and
install the retainer, bushing and bolt.
(5) Install the waterdam.
(6) Install the trim panel.
REAR DOOR WINDOW GLASS
REMOVAL
(1) Lower the window glass.
(2) Remove the trim panel.
BODY 23 - 47