Battery; Safety Guidelines While Using Internal Combustion Engines; Running The Engine; Fueling The Engine - Wacker Neuson 2503 Operator's Manual

Battery

2.16 Safety Guidelines while using Internal Combustion Engines

Running the engine

Fueling the engine

OM 25-3503 us – Edition 4.1 * 2503_3503b210_us.fm
• When handling the battery observe the specific safety instructions and regulations
relevant to accident prevention. Batteries contain caustic sulphuric acid.
• In case of a frozen battery or of an insufficient electrolyte level, do not try starting the
machine with battery jumper cables. The battery can burst or explode.
• Dispose of the battery immediately.
• A potentially combustible oxygen-hydrogen mixture forms in batteries during normal
operation and especially when charging. Always wear gloves and eye protection when
working with batteries.
WARNING W WARNUNG
Special hazard during operation and fueling.
Can cause severe injury or death.
• Read and follow the warning instructions and the safety guidelines below.
When running the engine:
• Keep the area around the muffer and exhaust pipe free of flammable materials.
• Check the fuel lines and the fuel tank for leaks and cracks before starting the engine.
Do not run the machine if fuel leaks are present or the fuel lines are loose.
• Engine exhaust CAN KILL YOU IN MINUTES. Engine exhaust contains carbon
monoxide. This is a poison you cannot see or smell. Never run the machine indoors
or in an enclosed area such as a deep trench unless adequate ventilation, through
such items as exhaust fans or hoses, is provided.
• Do not smoke while operating the machine.
• Do not run the engine near open flames.
• Do not touch the engine or exhaust while the engine is running or immediately after it
has been turned off.
• Do not operate a machine when its fuel cap is loose or missing.
• Do not remove the radiator cap when engine is running or hot. The radiator fluid is hot
and under pressure, and may cause severe burns.
When fueling the engine:
• Clean up any spilled fuel immediately.
• Refill the fuel tank in a well-ventilated area.
• Replace the fuel tank cap after refueling.
• Do not smoke.
• Do not refuel a hot or running engine.
Do not refuel the engine near an open flame
• Use suitable mounting points and load-securing devices.
• The recommissioning procedure must be strictly in accordance with the Operator's
Manual.
Safety instructions
2-19