Electrical And Ignition System; Battery Maintenance; Battery Removal - Polaris 2013 RANGER RZR S Service Manual

MAINTENANCE

ELECTRICAL AND IGNITION SYSTEM

Battery Maintenance

Keep battery terminals and connections free of corrosion.
If cleaning is necessary, remove the corrosion with a stiff
wire brush. Wash with a solution of one tablespoon baking
soda and one cup water. Rinse well with tap water and dry
off with clean shop towels. Coat the terminals with
dielectric grease or petroleum jelly.
CALIFORNIA PROPOSITION 65 WARNING:
Batteries, battery posts, terminals and related
accessories contain lead and lead compounds,
and other chemicals known to the State of
California to cause cancer and birth defects or
other reproductive harm.
WASH HANDS AFTER HANDLING.
Battery electrolyte is poisonous. It contains
sulfuric acid. Serious burns can result from
contact with skin, eyes or clothing. Antidote:
External: Flush with water.
Internal: Drink large quantities of water or milk.
Follow with milk of magnesia, beaten egg, or
vegetable oil. Call physician immediately.
Eyes: Flush with water for 15 minutes and get
prompt medical attention.
Batteries produce explosive gases.
Keep sparks, flame, cigarettes, etc. away.
Ventilate when charging or using in an enclosed
space. Always shield eyes when
working near batteries.
KEEP OUT OF REACH OF CHILDREN.
NOTE: Batteries must be fully charged before use or
battery life will be reduced by 10-30% of full
potential. Charge battery according to "Charging
Procedure" provided in Chapter 10. Do not use the
vehicle's stator/alternator to charge a new battery.
2.30
WARNING
WARNING
9924125 - 2013 RANGER RZR / RZR S / RZR 4 Service Manual
© Copyright 2012 Polaris Sales Inc.

Battery Removal

1. Remove the driver's seat to access the battery.
Battery
Battery
2. Disconnect the black (negative) battery cable.
3. Disconnect the red (positive) battery cable.
4. Remove the hold-down strap and lift the battery out
of the vehicle.
To reduce the chance of sparks: Whenever
removing the battery, disconnect the black
(negative) cable first. When reinstalling the
battery, install the black (negative) cable last.
RZR / RZR S
RZR 4
CAUTION