Toyota TERCEL 1985 Repair Manual page 14

Follow the severe condition schedule if vehicle is operated mainly under one or more of the following severe conditions:
• Pulling a trailer
• Repeated short trips
• Driving on rough and/or muddy roads
• Driving on dusty roads
• Driving in extremely cold weather and/or on salted roads
SEVERE CONDITION SCHEDULE
\ Service ¡nterval
\ (Odometer reading o
\ months, whichever
\ comes first)
System
ENGINE Valve clearance *
V-ribbed belt (Alternator)
Drive beltsC)
Conventional belt (PS and A/C)
Engine oil and oil filter *
Engine coolanr^)
Exhaust pipes and mountings
FUEL
Idle speed and fast idie speed
Choke system *
Throttle positioner system
Air f i l t e r * * (6)
Fuel line and connections
Fuel filler cap gasket
IGNITION
Spark plugs
Ignition wiring and distributor cap *
EVAP Charcoal canister
BRAKES Brake lining and drums
Brake pads and discs
Brake line pipes and hoses
CHASSIS
Steering linkage^
Drive shaft boots
Ball joints and dust covers
Automatic transmission, manual transmission,
differential and steering gear housing (8)
Rear wheel bearing grease (ex. wagón) (5)
Bolts and nuts on chassis and body(7)
Maintenance services indicated by a star (*) or asterisk (*) are required under the terms of the Emission Control Systems
Warranty. See Owner's Guide for complete warranty information.
* For vehicles sold in California
* For vehicles sold outside California
NOTE:
(1) After 60,000 miles (96,000 km) or 72 months, inspect every 10,000 miles (16,000 km) or 12 months.
(2) After 60,000 miles (96,000 km) or 72 months, replace every 30,000 miles (48,000 km) or 36 months.
(3) After 15,000 miles (24,000 km) or 18 months, adjustment is not necessary.
(4) In áreas where road salt is used, inspect and clean each year just after the snow season.
(5) Change every 45,000 miles (72,000 km) or 54 months.
(6) Applicable when operating mainly on dusty roads. If not, follow the normal condition schedule.
(7) Applicable when operating mainly on rough and/or muddy roads. If not, follow the normal condition schedule.
(8) Inspect the steering gear housing for oil leakage only.
MAINTENANCE — Maintenance Schedule
Maintenance services beyond 60,000 miles
r
(96,000 km) should be performed at the same intervals
shown in each maintenance schedule.
Miles x 1,000
10
5 7.5
\
Kmx 1,000
8 12 16
\
Months
6 9 12
R R
3A-C engine^)
3A engine
3A-C engine^
3A engine
I I
3A-C engine *
3A engine
I
I
I
I
¡ |
0
30 35 37.5 40
15 20 22.5 25
24 32 36 40 48 56 60 64
18 24 27 30 36 42 45 48
A A
I
R R R R R R
I I
A
A A
I
A
I I
I I I R I I
I
R
R R
(4)
I I
I I
I I
I I
R R
I I
M A - 3
See page
(item No.)
45 50 52.5 55 60
84 96
72 80 88
54 60 63 66 72
A MA-8(item 14)
A
I
MA-4(item 1)
I MA-4(item 2)
R R R R MA-6(item 7)
R MA-6(item 8)
I I MA-8(item 12)
MA-9(item 15)
MA-10(item 16)
A A
I MA-8(item 13)
MA-11(ítem 17)
I I MA-12(item 18)
I I R MA-5(ítem 3,4)
I MA-7(ítem 11)
R
MA-7(item 10)
R
MA-5(item 5)
R R
MA-6(item 6)
I
MA-6(item 9)
MA-13(ítem20)
I MA-13(item21)
MA-13(item 19)
MA-14(item22)
I
MA-14(item24)
I
I MA-14(item25)
MA-14(item23)
MA-15 (item 27)
R R
MA-16 (item 28)
MA-16 (item 29)
R MA-17 (item 30)
I MA-17(item31)
I