Suzuki Wagon R Manual page 3962

(Z10XEP AND Z12XEP ENGINES)
WARNING:
For vehicles equipped with a Supplemental Restraint (Air Bag) System:
• Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "System Components and Wiring Location View and Connec-
tors" under "General Description" in Section 10B in order to confirm whether you are performing
service on or near the air bag system components or wiring. Please observe all WARNINGS and
"Service Precautions" under "On-Vehicle Service" in Section 10B before performing service on or
around the air bag system components or wiring. Failure to follow WARNINGS could result in unin-
tentional activation of the system or could render the system inoperative. Either of these two condi-
tions may result in severe injury.
• Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system
may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
General Description ......................................6H4-2
Battery Description ......................................6H4-2
Carrier and hold-down.............................6H4-2
Electrolyte freezing..................................6H4-2
Sulfation ..................................................6H4-2
Built-in indicator (if equipped)..................6H4-2
Care of battery.........................................6H4-3
Generator Description .................................6H4-4
Diagnosis .......................................................6H4-5
Battery Inspection .......................................6H4-5
Visual inspection .....................................6H4-5
Generator Symptom Diagnosis ...................6H4-5
Charging indicator lamp operation ..........6H4-5
Undercharged battery..............................6H4-6
On-Vehicle Service........................................6H4-7
Jump Starting in Case of Emergency..........6H4-7
SECTION 6H4
CHARGING SYSTEM
CONTENTS
CHARGING SYSTEM (Z10XEP AND Z12XEP ENGINES) 6H4-1
With auxiliary (booster) battery ...............6H4-7
With charging equipment ........................6H4-7
Battery Dismounting and Remounting ........6H4-8
Dismounting ............................................6H4-8
Handling ..................................................6H4-8
Remounting.............................................6H4-8
Accessory Drive Belt Removal and
Installation...................................................6H4-8
Generator Components ..............................6H4-9
Generator Removal and Installation ...........6H4-9
Generator Disassembly and
Reassembly ..............................................6H4-10
Specification................................................6H4-10
Battery.......................................................6H4-10
Generator..................................................6H4-10
Tightening Torque Specification ...............6H4-10
6-3
6A3
6B3
6C3
6E3
6G3
6H4
6K3