Servicing; Recharging Operation - Suzuki DL650 Service Manual

8-42 ELECTRICAL SYSTEM
SERVICING
Visually inspect the surface of the battery container. If any signs
of cracking or electrolyte leakage from the sides of the battery
have occurred, replace the battery with a new one. If the battery
terminals are found to be coated with rust or an acidic white
powdery substance, clean the battery terminals with sandpaper.
RECHARGING OPERATION
Using the multi circuit tester, check the battery voltage. If the
voltage reading is less than the 12.0 V (DC), recharge the bat-
tery with a battery charger.
@
Charging period
0
Stop charging
(CAUTlONI
When recharging the battery, remove the battery
from the motorcycle.
Do not remove the caps on the battery top while
recharging.
Recharging time: 1.4 A for 5 to 10 hours or 6 A for one hour
Be careful not to permit the charging current to
exceed 6 A at any time.
After recharging, wait for more than 30 minutes and check the
battery voltage with a multi circuit tester.
If the battery voltage is less than the 12.5 V, recharge the bat-
tery again.
If battery voltage is still less than 12.5 V, after recharging,
replace the battery with a new one.
When the motorcycle is not used for a long period, check the
battery every 1 month to prevent the battery discharge.
0
10 20 30 40 50 60
Time (Minutes)
100
75 50 25
0 ('10)
Battety charged condition