Scheduled Maintenance Service Operations; Maintenance Service On A Shift Basis (Sbms) In Every 8 - 10 Hours Of Opera- Tion Or Per Shift - Belarus 922.6 Operator's Manual

5.4 Scheduled maintenance service operations

5.4.1 Maintenance service on a shift basis (SBMS) in every 8 – 10 hours of op-
eration or per shift
5.4.1.1 General instructions
Every 8 – 10 hours of tractor operation or at the end of shift (depending on which
comes first), do the following operations:
5.4.1.2 Operation 1. Check of oil level in the engine crankcase
Check oil level putting the tractor on a flat surface and not earlier than in 3-5 min after
the engine is off, when the oil completely flows to the crankcase.
To check oil level in the engine crankcase, do the following:
- take dipstick 3 out (Figure 5.4.1), wipe it clean and then put it back against the stop;
- take dipstick 3 out and define the oil level. The oil level shall stay between the upper
and lower marks of the dipstick. If required, top up the oil through neck 1 after removing cap
2;
- put cap 2 back.
ATTENTION: DO NOT RUN THE ENGINE WITH THE OIL LEVEL BELOW THE LOWER
MARK ON THE DIPSTICK!
ATTENTION: DO NOT TOP OIL ABOVE THE UPPER MARK OF THE DIPSTICK. THE OIL
BURNS OUT CREATING WRONG IMPRESSION OF LARGE OIL CONSUMPTION!
5.4.1.3 Operation 2. Alternator cleaning
Clean alternator 2 (Figure 5.4.2) against dust, blow with pressed air.
1 – oil filler neck; 2 – cap; 3 – dipstick.
Figure 5.4.1 – Check of oil level in the engine crankcase
1 – engine; 2 – alternator.
Figure 5.4.2 – Alternator cleaning
134
922.6-0000010 OM