Scheduled Maintenance Service Operations; Maintenance Service On A Shift Basis (Sbms) In Every 8 - 10 Hours Of Operation Or Per Shift - Belarus 1822.3 Operator's Manual

6.4 Scheduled maintenance service operations

6.4.1 Maintenance service on a shift basis (SBMS) in every 8 – 10 hours of op-
eration or per shift
6.4.1.1 General instructions
Every 8 – 10 hours of tractor operation or at the end of shift (depending on which
comes first), do the following operations:
6.4.1.2 Operation 1. Check of oil level in the engine crankcase
Check oil level putting the tractor on a flat surface and not earlier than in 3-5 min af-
ter the engine is off, when the oil completely flows to the crankcase.
To check oil level in the engine crankcase, do the following:
- take dipstick 3 out (figure 6.4.1), wipe it clean and then put it back against the stop;
- take dipstick 3 out and define the oil level. The oil level shall stay between the upper and
lower marks of the dipstick. If required, top up the oil through neck 1 after removing cap 2;
- put cap 2 back.
Figure 6.4.1 – Check of oil level in the engine crankcase
ATTENTION: DO NOT RUN THE ENGINE WITH THE OIL LEVEL BELOW THE LOWER
MARK ON THE DIPSTICK!
ATTENTION: DO NOT TOP OIL ABOVE THE UPPER MARK OF THE DIPSTICK. THE
OIL BURNS OUT CREATING WRONG IMPRESSION OF LARGE OIL CONSUMPTION
6.4.1.3 Operation 2. Check of oil level in the transmission
Check oil level visually according to oil level indicator 1 (figure 6.4.2), located on the
right side of the transmission housing. Oil shall be at the level not lower than 10mm from
the mark " ". If necessary, take off oil filler neck cap 3 (figure 6.4.44) of the oil filler neck
and refill the oil up to the required mark " ". Normal oil level shall be within
mark « ».
Figure 6.4.2 – Check of oil level in the transmission
1 – oil filler neck; 2 – cap; 3 – dipstick.
1 – oil level indicator; 2 – GB centrifugal oil filter
https://tractormanualz.com/
243
2022.3-0000010 OM
5 from the