Control Surface Travel And Cable Tension - Piper Cherokee Six Service Manual

Aileron
NOTES
1. Maximum
free play for aileron
is 0.24 of an Inch, measured at
trailing edge.
2.
Refer to Section IV, Paragraph
4-32.
3.
Maximum end
play
(Inboard/Outboard
must
not
exceed .035 of an Inch.
Stabilator
Stabilator
Trim Tab
NOTES
1. Maximum
free play
for
control
surface tab Is 0.15 of
an Inch measured
at tab
trailing edge.
2.
Refer to Section IV, Paragraph
4-32
3.
Neutral position
of stabilator
Is with the stabllator
chord
line parallel
with the leveling
holes noted In Figure 2-6.
Rudder
Flap
Rudder Pedal
PIPER CHEROKEE SIX SERVICE MANUAL
TABLE V-I.
CONTROL SURFACE TRAVEL AND CABLE TENSION
AILERON
CHORD LINE
16° + 1°UP
807
STABILATOR CHORD LINE
NEUTRAL POSITION,
SEE NOTE 3)
-
1681
Rudder Pedal Neutral Position
Aft of Vertical 11 14
°
+3 -1 on 1974 Models and up
Cable Tensions
Aileron
Flap
Stabilator
Stabilator
Trim Tab
Rudder
40 lbs ± 5 lbs
10 lbs ± 1 lb
40 lbs ± 5 lbs
14 lbs ± 1 lb
85 lbs ± 5 lbs
NOTE
CABLE TENSIONS GIVEN APPLY ONLY
TO AIRPLANES WITHOUT AUTOPILOT
BRIDLE CABLES ATTACHED. REFER TO
APPROPRIATE AUTOPILOT SERVICE
MANUAL FOR PROPER CABLE TENSIONS
WHEN ATTACHING BRIDLE CABLES.
Rudder
65 lbs + 5 lbs
PA-32R-300 ONLY
CONTROL SURFACES
Revised: 11/4/83
1G14