Piper SARATOGA II HP PA-32R-301 Manuals

Manuals and User Guides for Piper SARATOGA II HP PA-32R-301. We have 2 Piper SARATOGA II HP PA-32R-301 manuals available for free PDF download: Maintenance Manual, Pilot Operating Handbook

Piper SARATOGA II HP PA-32R-301 Maintenance Manual

Piper SARATOGA II HP PA-32R-301 Maintenance Manual (956 pages)

Brand: Piper | Category: Aircrafts | Size: 11 MB

Table of Contents

Maintenance Manual

30
- Table of Contents
  30
- Chapter 5 - Time Limits/Maintenance Checks
  31
- General
  31
- Time Limits
  32
  - Inspection Requirements
    32
  - Preflight Checks
    32
  - Overlimits Inspection
    32
- Scheduled Maintenance
  33
  - Definitions 1C8
    35
  - Inspection Requirements
    36
  - Periodic Inspection
    37
- Unscheduled Maintenance Checks
  52
  - General
    52
  - Special Inspections as Required, Upon Condition
    52
Piper Aircraft

54
- Chapter 6 - Dimensions and Areas
  61
- Station Reference Lines
  61
- Access and Inspection Provisions
  62
- July
  69
- Rissued: July
  78
Table of Contents

93
- Chapter 12 - Servicing
  95
- Servicing
  95
  - General
    95
  - Engine Cleaning
    95
  - Aircraft Finish Care
    95
    
    Cleaning
    95
    
    Cleaning Exterior Surfaces
    95
    
    Cleaning Headliner, Side Panels and Seats
    96
    
    Cleaning Windshield and Windows
    96
    
    Cleaning Carpets
    97
    
    Cleaning Landing Gear
    97
- Replenishing
  98
- Draining Moisture from Fuel System
  99
- Filling Fuel System
  99
- Servicing Fuel System
  99
- Draining Fuel System
  100
- Draining Oil Sump
  100
- Engine Lubrication
  100
- Filling Oil Sump
  101
- Oil Filter (Full Flow)
  101
- Oil Screen (Suction)
  101
- Recommendations for Changing Oil
  101
- Landing Gear
  102
- Servicing Oleo Struts
  102
- Filling Nose Gear Oleo Strut
  103
- Filling Main Gear Oleo Strut
  104
- Brake System
  105
- Filling Brake Cylinder Reservoir
  105
- Inflating Oleo Struts
  105
- Draining Brake System
  106
- Tires
  106
- Tire Balance
  107
- Hydraulic System
  108
- Servicing Engine
  108
Maintenance Manual

128
- Servicing Hydraulic Pump/Reservoir
  108
- Chapter 20 - Standard Practices/Airframe
  129
- General
  129
- Standard Practices - Airframe
  129
- Torque Wrenches
  129
- Method for Installing Rod End Bearings
  130
- Flareless Tube Assemblies
  132
- Identification of Fluid Lines
  132
- Electrical Bonding
  135
- Support Clamps
  136
Maintenance Manual

140
- Chapter Section
  141
- Section Subject Grid no
  141
- Chapter 21 - Environmental System
  142
- Environmental Sysrems
  142
  - General
    142
- Heating
  144
  - Description and Operation
    144
  - Heater Maintenance
    144
  - Heat, Defrost,And Overhead Vent System
    145
- Cooling
  148
  - Overhead Vent System
    148
    
    Assembling of Vent Blower
    148
    
    Disassembly of Vent Blower
    148
    
    Optional Overhead Vent Blower
    148
    
    Removal of Vent Blower Assembly
    148
  - Air Conditioning
    150
    
    Description and Operation
    151
    
    Air Conditioning Troubleshooting
    152
    
    Servicing of Air Conditioner
    157
    
    General Refrigeration System Procedures
    159
    
    Special Servicing Procedures
    159
    
    Service Valves
    160
    
    Service Valve Replacement
    161
    
    Test Gauge Manifold Set 1I4
    162
    
    Discharging System
    165
    
    Evacuating System
    166
    
    Charging Stand Method
    168
    
    Charging the System
    168
    
    Addition of Partial Charge to System
    171
    
    Component Service 1I13
    171
    
    Compressor Service
    171
    
    Compressor Installation
    172
    
    Compressor Removal
    172
    
    Checking Compressor Oil
    173
Table of Contents

270
- Chapter 27 - Flight Controls
  272
- Flight Controls
  272
  - General Information
    272
  - Description and Operation
    272
  - Standard Practices Andprocedures
    272
  - Control Cable Inspection
    274
  - Cable Maintneance
    277
  - Cable Fittings
    277
- Aileron Controls
  280
  - Troubleshooting Aileron Control System
    280
  - Control Column Removal
    281
  - Control Column Installation
    283
  - Aileron Control Cables Removal
    284
  - Aileron Control Cables Installation
    286
  - Aileron Bellcrank Assembly Removal
    287
  - Aileron Bellcrank Assembly Installation
    287
- Rudder and Trim Controls
  291
  - Troubleshooting Rudder Control System
    291
Maintenance Manual Rudder and Trim Controls. (Cont)

295
- To Install Rudder Trim Control
  296
- To Remove Rudder Trim Control
  296
- Figure 17
  297
- Rigging and Adjustment of Rudder Trim Controls
  297
- Rudder and Steering Pedal Assembly 2C1
  298
- Stabilator Controls
  305
  - C a Bl E te N Sio N 6 5 Lb S. ± 5 Lb S
    307
  - Stabilator Trim Rigging and Adjustment
    314
  - Stall Warning System
    315
  - Description an Operation
    315
  - Removal of Lift Detectors
    315
  - Installation of Lift Detector
    315
  - Adjustment of Lift Detector
    316
  - Figure 28
    323
  - Figure 33
    328
Table of Contents

333
- Figure 2
  338
- Chapter 28 - Fuel
  341
- Inboard Fuel Tank Installation
  341
- Fuel Cell Compartment
  342
- Molded Nipple Fittings Installation
  342
- Outboard Fuel Cell Removal
  342
- Cleaning of Fuel Cells
  344
- Handling and Storage of Fuel Cells
  344
- Inspection of Fuel Cells
  344
- Repair of Fuel Cells
  344
- Accessory Replacement
  348
- Fuel Cell Defect Repairs
  349
- Testing Fuel Cells
  349
- Outboard Fuel Cell Installation
  350
- Fuel System Inspection
  351
- Locking Fuel Cap
  351
  - Disassembly of Locking Fuel Cap
    351
  - Assembly of Locking Fuel Cap
    351
- Fuel Selector Valve
  355
  - Fuel Selector Valve and Filter Removal
    355
  - Cleaning Filter Assembly
    355
- Cleaning Fuel System
  356
- Electric Fuel Pump Removal
  357
  - Electric Fuel Pump Installation
    357
Effectivity

406
- Chapter 30 - Ice and Rain Protection
  441
- Hour Inspection
  441
- Repair Procedures for Individual Components
  443
  - Brush Replacement
    443
  - Repairing Brush Block Assembly 2I7
    443
  - Attaching Individual Brushes to Brush Retainer
    443
  - Alignment of New Brushes
    445
- Slip Rings
  445
  - Machining of Slip Rings
    445
  - Replacement of Slip Rings
    445
- Deicer Blades
  446
  - Resistance Check of Deicer Blade
    446
  - Repair of Deicer Lead Strap
    447
  - Removal of Deicer
    448
  - Blade Preparation
    448
  - Cement Application 2I12
    448
  - Installation of Deicer and Required Materials
    449
  - Wrinkled Deicers 2I16
    450
  - Electrical Check
    452
  - Installation of Deicer Straps and Wire Harness
    453
  - Final Electric Check
    455
  - Other Components 2I19
    455
  - Timer Test (Prop Deice) 2I19
    456
  - Ice Viewing Light
    459
  - Removal of Ice Viewing Light
    459
  - Installation of Ice Viewing Light
    459

Advertisement

Piper SARATOGA II HP PA-32R-301 Pilot Operating Handbook

Piper SARATOGA II HP PA-32R-301 Pilot Operating Handbook (471 pages)

Brand: Piper | Category: Aircrafts | Size: 11 MB

Table of Contents

Pilot's Operating Handbook Log of Revisions
5
Table of Contents
13
Table of Contents
16
General
16
Introduction
18
Three View
19
Engine
20
Propeller
20
Fuel
21
Oil
21
Maximum Weights
22
Standard Airplane Weights
22
Baggage Space
22
Specific Loading
22
Symbols, Abbreviations and Terminology
23
- Limitations
  31
- Airspeed Limitations
  33
- General
  33
- Airspeed Indicator Markings
  34
- Power Plant Limitations
  35
- Power Plant Instrument Markings
  36
- Weight Limits
  36
- Center of Gravity Limits
  37
- Flight Load Factors
  37
- Maneuver Limits
  37
- Fuel Limitations
  38
- Types of Operation
  38
- Placards
  40
- Emergency Procedures
  46
- Paragraph Page
  47
- Emergency Procedures Checklist
  48
- General
  48
- Engine Fire During Start
  49
- Engine Power Loss During Takeoff
  49
- Engine Power Loss in Flight
  49
- Power off Landing
  50
- Engine-Driven Fuel Pump Failure
  51
- Fire in Flight
  51
- Loss of Fuel Flow
  51
- Loss of Oil Pressure
  51
- Electrical Failures
  52
- Electrical Overload
  53
- Propeller Overspeed
  53
- Emergency Landing Gear Extension
  54
- Spin Recovery
  54
  - Emergency Procedures (General)
    56
  - Engine Fire During Start
    56
  - Engine Power Loss During Takeoff
    56
  - Engine Power Loss in Flight
    57
  - Power off Landing
    58
  - Fire in Flight
    59
  - Loss of Fuel Flow
    60
  - Loss of Oil Pressure
    60
  - Electrical Failures
    61
  - Engine Driven Fuel Pump Failure
    61
  - High Oil Temperature
    61
  - Emergency Landing Gear Extension
    63
  - Propeller Overspeed
    63
  - Spin Recovery
    63
  - Engine Roughness
    64
- Open Door
  64
- Normal Procedures
  67
- Paragraph Page
  68
- Airspeeds for Safe Operations
  69
- General
  69
- Normal Procedures Checklist
  71
- Preflight Check
  71
- Before Starting Engine
  74
- Engine Start General
  74
- Normal Start- Cold Engine
  74
- Normal Start- Hot Engine
  75
- Starting with External Power Source
  75
- Ground Check
  76
- Warm-Up
  76
- Before Takeoff
  77
- Takeoff
  77
- Approach and Landing
  78
- Climb
  78
- Cruise
  78
- Go-Around
  79
- Stopping Engine
  79
- Mooring
  80
- Cockpit
  81
- Preflight Check
  81
  - Nose Section
    82
  - Right Wing
    82
  - Fuselage
    83
  - Left Wing
    83
  - Engine Start-General
    84
  - Miscellaneous
    84
- Before Starting Engine
  85
  - Cold Engine
    85
  - Hot Engine
    85
  - Starting Engine
    85
  - Starting Engine with External Power Sources
    86
  - Taxing
    87
- Warm-Up
  87
  - Ground Check
    89
  - Before Takeoff
    90
  - Takeoff
    90
  - Climb
    91
  - Cruising
    91
  - Short Field Technique
    91
  - Approach and Landing
    93
  - After Landing
    94
  - Go-Around
    94
  - Mooring
    94
  - Stopping Engine
    94
  - Landing Gear
    95
  - Stalls
    95
  - Turbulent Air Operation
    95
  - Noise Level
    96
  - Weight and Balance
    96
  - Introduction - Performance and Flight Planning
    100
  - Performance
    100
  - Demonstrated Operating Temperature
    101
  - Flight Planning Example
    102
  - Takeoff and Landing
    103
  - Cruise
    105
  - Descent
    105
  - Total Flight Time
    106
  - Total Fuel Required
    107
  - Performance Graphs
    108
  - Temperature Conversion
    110
  - ISA Conversion
    111
  - Airspeed System Calibration All Flap Deflections
    112
  - Wind Components
    113
  - Normal Procedure Takeoff Performance
    115
  - Normal Procedure Takeoff Ground Roll
    116
  - Maximum Effort Takeoff Performance
    117
  - Maximum Effort Takeoff Ground Roll
    118
  - Maximum Rate of Climb, Gear up
    120
  - Fuel, Time and Distance to Climb
    122
  - Power Setting Table
    123
  - Speed - Idgh Speed Cruise
    124
  - Speed -Normal Cruise Power
    125
  - Speed -Economy Cruise Power
    126
  - Speed ·Long Range Cruise Power
    127
  - Range - Nautical Miles
    128
  - Endurance- Hours
    129
  - Fuel, Time and Distance to Descend
    130
  - Glide Range
    131
  - Landing Performance
    132
  - Landing Ground Roll
    133
  - Airplane Weighing Procedure
    140
  - Weighing Form
    142
  - Weight and Balance Data and Record
    143
  - Airplane Basic Empty Weight
    144
  - Airplane Useful Load -Normal Category Operation
    144
  - General Loading Recommendations
    147
  - Optional Six Seat Configuration
    147
  - Weight and Balance Determination for Flight
    148
  - Sample Loading Problem
    149
  - Weight and Balance Loading Form
    150
  - Loading Graph
    151
  - C.g. Range and Weight
    152
  - Description and Operation of the Airplane and Its Systems
    154
- Airframe
  156
- The Aeroplane
  156
- Engine and Propeller
  157
- Engine Controls
  159
  - Control Quadrant and Console
    160
  - Horizon Engine Instrument/Engine Monitoring System
    162
- Horizon Engine Instrument/Engine Monitoring System
  164
  - Fuel Management (Fuel)
    165
  - Top Level Operations
    165
  - Fuel Management Display #1
    167
  - Fuel Management Display #2
    167
  - Electrical Display (Elec)
    168
  - Engine Instrument Display
    168
  - Exceedance Display (Excd)
    169
  - Percent Power Display (%Pwr)
    170
  - Ddmp Maintenance Mode
    172
  - Temperature Display (Temp)
    172
  - Auxiliary Communications
    173
- Landing Gear
  175
  - Landing Gear Electrical Schematic
    177
  - Landing Gear Hydraulic System Schematic
    178
- Flight Controls
  179
  - Flight Control Console
    180
  - Electric Flap Schematic
    181
- Fuel System
  182
  - Fuel System Schematic
    184
  - Fuel Drain Lever
    185
- Electrical System
  186
  - Switch Panels
    186
  - Circuit Breaker Panel
    189
- Vacuum System
  190
- Typical Instrument Panel
  191
- Instrument Panel
  192
- Pitot-Static System
  192
- Cabin Features
  193
- Baggage Area
  196
- Heating and Ventilating System
  197
- Air Conditioning
  199
- Finish
  199
- Stall Warning
  199
- Emergency Locator Transmitter
  201
- External Power
  201
  - Artex 110-4 ELT Operation
    202
  - Airplane Handling, Servicing and Maintenance
    205
  - Airplane Inspection Periods
    210
  - Preventive Maintenance
    211
  - Airplane Alterations
    212
  - Ground Handling
    213
  - Towing
    213
  - Parking
    214
  - Cleaning Engine Air Filter
    215
  - Engine Air Filter
    215
  - Removing Engine Air Filter
    215
  - Brake Service
    216
  - Brake System
    217
  - Landing Gear Service
    218
  - Oil Requirements
    219
  - Propeller Service
    219
  - Servicing Fuel System
    219
  - Fuel Grade Comparison Chart
    220
  - Fuel Requirement
    220
  - Draining Fuel Strainer, Sumps and Lines
    221
  - Filling Fuel Tanks
    221
  - Fuel Tank Drain
    222
  - Battery Service
    223
  - Tire Inflation
    223
  - Cleaning
    224
  - Cleaning Engine Compartment
    224
  - Cleaning Exterior Surfaces
    225
  - Cleaning Landing Gear
    225
  - Cleaning Carpets
    226
  - Cleaning Headliner, Side Panels and Seats
    226
  - Cleaning Windshield and Windows
    226
  - Supplements
    228
  - Pilot's Operating Handbook and FAA Approved Airplane Flight Manual
    232
- General
  233
  - Supplement 2 for Auxiliary Vacuum System
    236
  - Description and Operation
    239
  - Weight & Balance
    239
- Bendix/King KLN 90B GPS Navigation System with KAP/KFC 150 Autopilot System
  242
- KAP/KFC 150 Autopilot System
  242
- Garmin Gtx 327 Transponder
  304
  - GTX 327 Configuration Mode
    307
  - Mode Selection Keys
    307
  - Code Selection
    308
  - To Use the GTX 327 Configuration Mode
    308
  - Important Codes
    309
  - Keys for Other GTX 327 Functions
    309
  - Altitude Trend Indicator
    311
  - Timer Operation
    311
  - To Operate the Count up Timer
    311
  - To Operate the Flight Timer
    311
  - Automatic ALT/STBY Mode Switching
    312
  - S-Tec System 55X Two Axis Automatic Flight Guidance System
    314
  - Emergency Operating Procedures
    318
  - Operating Limitations
    318
  - Piper Models Pa-32R-301 and Pa-32R-301 T
    319
  - Piper Models Pa-32R-301 and Pa-32R-301T
    320
  - Control Wheel Switches
    321
  - Electric Trim System
    321
  - TRIM System with Trim Monitor
    321
  - Manual Electric Trim
    322
  - Preflight Trim Check (with Trim Monitor)
    322
  - System Description
    322
  - Auto Trim
    323
  - Glide Slope Flight Procedure
    324
- S-TEC ADF 650A System
  326
  - ADF Test (Pre-Flight or In-Flight)
    328
  - To Operate as an Automatic Direction Finder
    328
  - To Operate BFO
    328
  - ADF-650A Receiver, Controls, and Indicators
    329
  - Bfomode
    329
  - ADF Mode
    330
  - ANT (Antenna) Mode
    330
  - Frequency Selector Controls
    330
  - Self Test Switch
    330
  - Garmin Gma 340 Audio Panel
    332
  - ON/OFF, Pilot Intercom System (ICS) Volume Control
    335
  - Split COM
    335
  - Transceivers
    335
  - Aircraft Radios and Navigation
    336
  - Intercom System (ICS)
    336
  - PA Function
    336
  - Speaker Output
    336
  - Marker Beacon Receiver
    337
  - S-Tec Dme-450
    338
  - Mode Selector Switch
    341
- Garmin Gtx 330 Transponder
  342
- Avidyne Flightmax Entegra Primary Flight/Multi-Function Displays
  346
  - Entegra 700-00006-0XX-() Primary Flight Display
    347
  - EX5000 Series 700-00004-0XX-() Multi-Function Display
    348
  - MFD Limitations
    349
  - PFD Limitations
    349
  - CMAX CHART PAGE Limitations
    351
  - Engine Start - General
    364
  - Starting with External Power Source
    367
  - Air Data
    368
  - Attitude Data
    368
  - Attitude Direction Indicator (ADI)
    368
  - PFD Systems Description
    368
  - Heading Data
    369
  - Horizontal Situation Indicator (HSI)
    369
  - Navigation Data
    369
  - Autopilot Integration
    370
  - Engine Instruments
    371
  - Back-Up Instruments
    372
  - MFD Systems Description
    373
  - Navigation
    373
  - Data Link
    374
  - Setup
    374
- MID-Continent 4300-4Xx Series Electric Attitude Indicator
  376
- Tks Ice Protection System (Non-Fiki Installation)
  380
- Ice Protection Fluid
  382
- In Flight
  385
- Inadvertent Icing Encounter
  387
- Descent I Landing
  388
- Final Approach
  388
- PA-32 General Location of TKS Equipment
  391
- Magnified View of Holes Laser Drilled through Titanium
  392
- TKS Porous Panel Cross Section
  392
- PA-32 TKS System Fluid Schematic
  394
- Contents Indicator Gauge
  396
- System Electrical Schematic
  396
- TKS System Electrical Controls
  398
- Avidyne Equipped Aircraft
  398
- Non-Avidyne Aircraft
  398
- Inactive TKS System
  399
- Prolonged Out-Of-Service Care
  401
- During Flyable Storage
  401
- De-Icing Fluid Tank
  401
- System Drain Valve Location
  402
- Pump Priming
  403
- System Fluid Filter
  403
- De-Icing Fluid Strainer
  403
- Porous Leading Edge Panels
  404
- Overhaul or Replacement Guide
  405
- Operating Tips
  408
- Flight in Unexpected Icing Conditions
  408
- S-Tec Adf -650D System
  410
- To Turn on the ADF -650D System
  412
- To Turn off the ADF -650D System
  412
- To Perform the Preflight Checklist and Self Test
  413
- RCR-650D Receiver Controls
  414
- Beat Frequency Oscillator (BFO) Mode
  414
- Automatic Direction Finder (ADF) Mode
  415
- Antenna (ANT) Mode
  415
- Frequency Selection Keypad
  415
- Power (PWR) Control
  415
- Clear (CLR)
  416
- Volume (VOL) Control
  416
- Display
  417
- Contrast
  417
- Volume
  417
- Function (FUNC) Selector
  417
- Keypad Light Brightness
  418
- Mode Selector
  418
- Ident (ID)
  418
- Test Mode
  419
- Avidyne Flightmax Entegra Primary Flight/Multi-Function Displays with the B&C Specialties BC410 Standby Alternator
  420
- Aircraft Engine Power Loss
  438
- Loss of Headidg Accuracy
  439
- Equipment List
  459

Advertisement

Related Products

Piper Categories

Aircrafts Tools Toy Commercial Food Equipment

Oven

More Piper Manuals