Club Car Carryall 295 Maintenance And Service Manual page 152

11
Troubleshooting Guide
TROUBLESHOOTING GUIDE
SYMPTOM
Engine starts but does not run smoothly.
Engine turns but fails to start.
Engine overheats.
Engine pre-ignites.
TABLE CONTINUED ON NEXT PAGE
Page 11-2 2008-2012 All-Wheel Drive Maintenance and Service Manual
POSSIBLE CAUSES
Spark plug is fouled or in poor condition
Spark plug wire is damaged or loose
Intermittent ignition coil failure
Water or dirt in the fuel system and/or
carburetor; dirty or clogged fuel filter
Fuel pump malfunction; fuel pressure to
carburetor too low
Fuel tank is empty
Fuel line or filters clogged
Fouled spark plug
Spark plug wire damaged or loose
Engine flooded with fuel as result of excess
choking
Fuel pump malfunction or failure
Ignition coil failure
Kill circuit grounded
Carburetor solenoid failure
Improper idle governor adjustment
Fan screen is partially blocked or plugged
Governor is improperly adjusted
Carburetor is too lean; check main jet size
Excessive carbon deposits on piston head or
in combustion chamber
Spark plug heat range is incorrect
Unsuitable or contaminated fuel
TROUBLESHOOTING AND ELECTRICAL
SYSTEM: GASOLINE VEHICLES
REFER TO
Spark Plugs on page 10-13
See the Kawasaki FH680D engine manual
(CC P/N 103351201).
Test Procedure 21 – Ignition Spark on page
11-27, Test Procedure 22 – Engine Kill Wire
on page 11-28, and Test Procedure 23 –
Grounded Kill Wire on page 11-28
Fuel System on page 15-8
Fuel System on page 15-8
Fuel System on page 15-8
Fuel System on page 15-8
Spark Plugs on page 10-13
See Section 15 – Gasoline Engine, Muffler,
Fuel System, and Clutches.
See owner's manual, Controls and Indicators.
See Choke.
Fuel System on page 15-8
Test Procedure 21 – Ignition Spark on page
11-27, Test Procedure 22 – Engine Kill Wire
on page 11-28, and Test Procedure 23 –
Grounded Kill Wire on page 11-28
Test Procedure 23 – Grounded Kill Wire on
page 11-28
Test Procedure 27 – Carburetor Solenoid
Circuit on page 11-30
Fuel System on page 15-8
See the Kawasaki FH680D engine manual
(CC P/N 103351201).
Fuel System on page 15-8
See the Kawasaki FH680D engine manual
(CC P/N 103351201).
See the Kawasaki FH680D engine manual
(CC P/N 103351201).
Spark Plugs on page 10-13
Fuel System on page 15-8