Fuel Filter; Fuel Pump; Carburetor - Club Car Carryall 295 Maintenance And Service Manual

15
Fuel System

FUEL FILTER

See General Warnings, Section 1, Page 1-2.
One in-line filter (4) is installed between the fuel tank and the fuel pump (Figure 15-5, Page 15-8). Fuel filters, fuel
lines, and the fuel tank vent should be inspected periodically for leaks and replaced when necessary. Filter changes
should not exceed the recommended interval. See Periodic Service Schedule on page 10-1. Replace the fuel filter
as instructed. See the Kawasaki FH680D engine manual (CC P/N 103351201).

FUEL PUMP

See General Warnings, Section 1, Page 1-2.
Procedures for inspection, removal, and installation can be found in the engine manual. See the Kawasaki FH680D
engine manual (CC P/N 103351201).

CARBURETOR

See General Warnings, Section 1, Page 1-2.
WARNING
• The carburetor is equipped with an electric heater and must be grounded to the engine in order to
prevent the risk of a spark. Always have a ground wire properly installed.
Before suspecting the carburetor as the cause of poor engine performance, make sure the fuel and ignition systems
are in proper operating condition. Check the following items:
• Spark plug and gap condition. See the Kawasaki FH680D engine manual (CC P/N 103351201).
• Air filter element. See Air Filter Replacement on page 15-26.
• Fuel filters. See Fuel Filter on page 15-10.
• Choke and air intake system (for restriction of air flow). See Air Intake System on page 15-26.
• Fuel pump. See the Kawasaki FH680D engine manual (CC P/N 103351201).
• Fuel lines (from fuel tank to filter to pump to carburetor). See Fuel Lines on page 15-8.
• Exhaust system (for restrictions).
If the carburetor has failed, replace it. See the Kawasaki FH680D engine manual (CC P/N 103351201).
Carburetor Grounding
WARNING
• The carburetor is equipped with an electric heater and must be grounded to the engine in order to
prevent the risk of a spark. Always have a ground wire properly installed.
The carburetor is equipped with an electric heater and must be grounded to the engine in order to prevent the risk of a
spark. Always have a ground wire installed (Figure 15-7, Page 15-11). If a ground wire is not present and installed
properly, do not operate the vehicle until carburetor is properly grounded. A Ground Wire Kit (CC P/N 103474701) is
available through Service Parts.
Page 15-10 2008-2012 All-Wheel Drive Maintenance and Service Manual
GASOLINE ENGINE, MUFFLER, FUEL
SYSTEM, AND CLUTCHES