Section 3 Operation; Pre-Operation Check - Will Burt NIGHT SCAN LITE Instructions Manual

Section 3
This section describes operation of the system. The exact operating procedures will vary based
on the configuration of your system. Follow the appropriate operation procedures for your
system. Use care to understand and follow all precautions while operating.

3.1 Pre-Operation Check

Before operating the system, ensure:

All operators read and understand the entire operation procedure.

The Mast System is properly installed.

The system is undamaged. If damage is apparent, do not use the system and have it
serviced prior to use.

All electrical cables are undamaged and properly terminated.

That the vehicle is not moving and is on level terrain.

Ensure that the following precautions are understood and followed:
Electrocution Hazard! Mast section are highly conductive to electrical current. Ensure the area
is free of overhead power lines and other unwanted sources of electricity. Follow applicable
safety regulations when working near energized power lines. Operator death may occur by
extending the mast into power lines. Be sure to allow sufficient clearance on all sides of the
Mast System to allow for side sway. Death or serious injury could result if proper precautions
are not performed.
Relocation/Driving Hazard! Do not relocate the system during operation or while the mast is
extended to any height above the nested position or powered up. Do not move vehicle until the
mast has been securely nested and powered down. Power-up and operate the mast only if the
vehicle is stationary and securely parked with the parking brake properly applied. Do not
operate without the vehicle interlock safety circuit installed. Relocating the system during
operation or after mast is extended could result in death or serious injury.
Trained Personnel Only! Only trained and qualified personnel should perform operating
procedures. Deviation from standard operating conditions and procedures could cause
dangerous Mast System failure.
TP-5554501-B
May 2019
I
NSTRUCTIONS FOR
Operation
Original Instructions
N S L & I
IGHT CAN ITE NFLEXION
HD
3-1