Every 500 Service Hours; Replacing Fuel Filter Cartridge; Changing Chain Case Oil - Kubota SSV65 Operator's Manual

EVERY 500 SERVICE HOURS

Do all 50 and 250 hour servicing at the same time.
BReplacing Fuel Filter Cartridge
To avoid personal injury or death:
A Keep fire away.
1. Remove the filter cartridge with the filter wrench.
2. Apply a small amount of fuel to the gasket of the
replacement filter and tighten it by hand.
(1) Fuel filter cartridge
A After exchange of the filter, the fuel system must be
purged of air.
A If you don't replace the fuel filter cartridge regularly,
the cleaning efficiency of the DPF (3000 hours) will be
reduced and the DPF longevity will be shorter than
expected.
REGULAR CHECKS AND MAINTENANCE WORK
BChanging Chain Case Oil
To avoid personal injury or death:
A Raise the lift arms and install the lift arm
stopper, stop the engine and remove the key
before undertaking the oil change.
1. Remove the drain plugs to let the oil run out. Screw in
and tighten the drain plugs again and fill with hydraulic
oil through the oil filling port.
2. Fill oil until it overflows out of the oil check port.
3. Use prescribed hydraulic oil. (See "RECOMMENDED
OILS" section.)
(1) Oil filling port
(2) Drain plugs
(3) Oil check port
Hydraulic oil volume
73
SSV65 20.5 L each
SSV75 28.0 L each