Chrysler Sebring 2004 Service Manual page 2421

DRIVEABILITY - NGC
P2074-MANIFOLD PRESSURE/THROTTLE POSITION CORRELATION -
HIGH FLOW/VACUUM LEAK —
TEST
13 Turn the ignition off.
Disconnect the MAP Sensor harness connector.
Disconnect the PCM harness connector.
Measure the resistance between ground and the (K6) 5 Volt Supply circuit at the
MAP Sensor harness connector.
Is the resistance above 100k ohms?
Yes → Go To 14
→ Repair the short to ground in the (K6) 5 Volt Supply circuit.
No
14 Turn the ignition off.
Disconnect the MAP Sensor harness connector.
With the DRBIII , monitor the MAP Sensor voltage.
Ignition on, engine not running.
Connect a jumper wire between the (K1) MAP Sensor Signal circuit and the (K4)
Sensor ground circuit .
Cycle the ignition switch from off to on.
With the DRBIII , monitor the MAP Sensor voltage.
Does the DRBIII display MAP voltage from approximately 4.9 volts to below 0.5
volt?
Yes → Replace the MAP Sensor.
→ Go To 15
No
15 Turn the ignition off.
Disconnect the MAP Sensor harness connector.
Disconnect the PCM harness connector.
CAUTION: DO NOT PROBE THE PCM HARNESS CONNECTORS. PROBING
THE PCM HARNESS CONNECTORS WILL DAMAGE THE PCM TERMI-
NALS RESULTING IN POOR TERMINAL TO PIN CONNECTION. INSTALL
MILLER SPECIAL TOOL #8815 TO PERFORM DIAGNOSIS.
Measure the resistance of the (K1) MAP Signal circuit from the MAP Sensor harness
connector to the appropriate terminal of special tool #8815.
Is the resistance below 5.0 ohms?
Yes → Go To 16
→ Repair the (K1) MAP Signal circuit.
No
16 Turn the ignition off.
Disconnect the MAP Sensor harness connector.
Disconnect the PCM harness connector.
Measure the resistance between ground and the (K1) MAP Signal circuit at the MAP
Sensor harness connector.
Is the resistance above 100k ohms?
Yes → Go To 17
→ Repair the (K1) MAP Signal circuit.
No
Continued
ACTION
Perform POWERTRAIN VERIFICATION TEST VER - 5 - NGC.
Perform POWERTRAIN VERIFICATION TEST VER - 5 - NGC.
Perform POWERTRAIN VERIFICATION TEST VER - 5 - NGC.
Perform POWERTRAIN VERIFICATION TEST VER - 5 - NGC.
492
APPLICABILITY
All
All
All
All