Installation - Dodge Sprinter 2006 Manual

VA
Fig. 10 Control Module Bracket
1 - SEAT RISER
2 - SCREW (2)
3 - CONTROL MODULE BRACKET
(6) Rem ove t h e con t r ol m odu le br a cket fr om t h e
t op of t h e dr iver side sea t r iser.
(7) Loca t e t h e Air ba g Con t r ol Modu le (ACM) in t h e
r igh t r ea r cor n er of t h e a r ea wit h in t h e dr iver side
sea t r iser. F ir m ly gr a sp a n d pu ll u pwa r d on t h e
m olded pla st ic cover t o u n sn a p it fr om over t h e ACM
(F ig. 11).
Fig. 11 ACM Cover
1 - SEAT RISER
2 - COVER
3 - ACM
(8) Rem ove t h e t h r ee scr ews t h a t secu r e t h e ACM
t o t h e br a cket t h a t is welded on t o t h e floor pa n el
u n der t h e dr iver side fr on t sea t (F ig. 12).
Fig. 12 Airbag Control Module Remove/Install
1 - ACM LABEL
2 - ACM
3 - SCREW (3)
4 - GROUND EYELET
5 - CONNECTOR
(9) Lift t h e ACM u pwa r d fa r en ou gh t o a ccess t h e
ACM wir in g con n ect ion . Depr ess t h e r elea se a n d lift
t h e lever a r m t o discon n ect t h e veh icle wir e h a r n ess
con n ect or for t h e ACM fr om t h e ACM con n ect or
r ecept a cle loca t ed on t h e left fa cin g side of t h e m od-
u le.
(10) Rem ove t h e ACM fr om wit h in t h e dr iver side
fr on t sea t r iser.
INSTALLA TION
WARNING: To avoid personal injury or death, on
vehicles equipped with airbags, disable the supple-
mental restraint system before attempting any
steering wheel, steering column, airbag, seat belt
tensioner, impact sensor, or instrument panel com-
ponent diagnosis or service. Disconnect and isolate
the battery negative (ground) cable, then wait two
minutes for the system capacitor to discharge
before performing further diagnosis or service. This
is the only sure way to disable the supplemental
restraint system. Failure to take the proper precau-
tions could result in accidental airbag deployment.
WARNING: To avoid personal injury or death, never
strike or drop the airbag control module as it can
damage the impact sensor or affect its calibration.
The airbag control module contains the impact sen-
sor, which enables the system to deploy the supple-
mental restraints. If an airbag control module is
accidentally dropped during service, the module
must be scrapped and replaced with a new unit.
Failure to observe this warning could result in acci-
dental, incomplete,
restraint deployment.
RESTRAINTS 8O - 11
or improper supplemental