Standard Procedure - Verification Test - Dodge Sprinter 2006 Manual

VA
(1) Begin t h e clea n u p by u sin g a va cu u m clea n er
t o r em ove a n y r esidu a l powder fr om t h e veh icle in t e-
r ior. Clea n fr om ou t side t h e veh icle a n d wor k you r
wa y in side, so t h a t you a void kn eelin g or sit t in g on a
n on -clea n ed a r ea .
(2) Be cer t a in t o va cu u m t h e h ea t er a n d a ir con di-
t ion in g ou t let s a s well (F ig. 4). Ru n t h e h ea t er a n d
a ir con dit ion er blower on t h e lowest speed set t in g
a n d va cu u m a n y powder expelled fr om t h e ou t let s.
Fig. 4 Vacuum Heater and A/C Outlets - Typical
CAUTION: All damaged, faulty, or non-deployed
supplemental restraints which are replaced on vehi-
cles are to be handled and disposed of properly. If
an airbag unit or seat belt tensioner unit is faulty or
damaged and non-deployed, refer to the Hazardous
Substance Control System for proper disposal. Be
certain to dispose of all non-deployed and deployed
supplemental restraints in a manner consistent with
state, provincial, local and federal regulations.
(3) Next , r em ove
r est r a in t s fr om t h e veh icle. Refer t o t h e a ppr opr ia t e
ser vice r em ova l pr ocedu r es.
(4) You m a y n eed t o va cu u m t h e in t er ior of t h e
veh icle a secon d t im e t o r ecover a ll of t h e powder.
STANDARD PROCEDURE - VERIFICA TION TEST
Th e followin g pr ocedu r e sh ou ld be per for m ed u sin g
a dia gn ost ic sca n t ool t o ver ify pr oper su pplem en t a l
r est r a in t syst em oper a t ion followin g t h e ser vice or
r epla cem en t of a n y su pplem en t a l r est r a in t syst em
com pon en t .
WARNING: To avoid personal injury or death, on
vehicles equipped with airbags, disable the supple-
mental restraint system before attempting any
steering wheel, steering column, airbag, seat belt
tensioner, impact sensor, or instrument panel com-
ponent diagnosis or service. Disconnect and isolate
the battery negative (ground) cable, then wait two
minutes for the system capacitor to discharge
t h e deployed su pplem en t a l
before performing further diagnosis or service. This
is the only sure way to disable the supplemental
restraint system. Failure to take the proper precau-
tions could result in accidental airbag deployment.
(1) Du r in g t h e followin g t est , t h e ba t t er y n ega t ive
ca ble r em a in s discon n ect ed a n d isola t ed, a s it wa s
du r in g t h e su pplem en t a l r est r a in t syst em com pon en t
r em ova l a n d in st a lla t ion pr ocedu r es.
(2) Be cer t a in t h a t t h e dia gn ost ic sca n t ool con -
t a in s t h e la t est ver sion of t h e pr oper dia gn ost ic soft -
wa r e. Con n ect t h e dia gn ost ic t o t h e 16-wa y Da t a
Lin k Con n ect or (DLC). Th e DLC is loca t ed on t h e
da sh pa n el ben ea t h t h e dr iver side lower edge of t h e
in st r u m en t pa n el, ou t boa r d of t h e st eer in g colu m n
(F ig. 5).
Fig. 5 16-Way Data Link Connector
1 - BOTTOM OF INSTRUMENT PANEL
2 - CONNECTOR COVER
3 - 16-WAY DATA LINK CONNECTOR
4 - DASH PANEL
5 - INSIDE HOOD RELEASE LEVER
(3) Tu r n t h e ign it ion swit ch t o t h e On posit ion a n d
exit t h e veh icle wit h t h e dia gn ost ic sca n t ool.
(4) Ch eck t o be cer t a in t h a t n obody is in t h e veh i-
cle, t h en r econ n ect t h e ba t t er y n ega t ive ca ble.
(5) Usin g t h e dia gn ost ic, r ea d a n d r ecor d t h e
a ct ive (cu r r en t ) Dia gn ost ic Tr ou ble Code (DTC) da t a .
(6) Next , u se t h e dia gn ost ic t o r ea d a n d r ecor d a n y
st or ed (h ist or ica l) DTC da t a .
(7) If a n y DTC is fou n d in St ep 5 or St ep 6, r efer
t o t h e a ppr opr ia t e dia gn ost ic in for m a t ion .
(8) Use t h e dia gn ost ic t o er a se t h e st or ed DTC
da t a . If a n y pr oblem s r em a in , t h e st or ed DTC da t a
will n ot er a se. Refer t o t h e a ppr opr ia t e dia gn ost ic
in for m a t ion t o dia gn ose a n y st or ed DTC t h a t will n ot
er a se. If t h e st or ed DTC in for m a t ion is su ccessfu lly
er a sed, go t o St ep 9.
(9) Tu r n t h e ign it ion swit ch t o t h e Off posit ion for
a bou t fift een secon ds, a n d t h en ba ck t o t h e On posi-
t ion . Obser ve t h e a ir ba g in dica t or in t h e in st r u m en t
clu st er. It sh ou ld illu m in a t e for fou r secon ds, a n d
t h en go ou t . Th is in dica t es t h a t t h e su pplem en t a l
RESTRAINTS 8O - 7