Honda 1986 GoldWing GL1200A Manual page 125

ABNORMAL INCREASE OPERATION.
NOTES:
• System will not won< when front or rear brake is applied.
• Air pump will stop automatically after about 90 seconds of operation.
• System does not operate when battery voltage is below 10 V.
•
Air will stop increasing automatically at 10 Kg/cm 2 (14 psi) for front, and 6.5 kg!cm 2 192 psi) for rear.
ty y
Does Not
PUMP: ChecK air pump operation by
Operate
PUMP: Check air pump operation by
pressing air outlet button with ignition
applying battery voltage to pump coupler,
switch at "P"
Operates
~
Operates
Does Not
•
Open Circuit in sub
Operate
harness.
RELAY: Replace air pump relay with a
Operates
•
Loose or poorly
•
Faulty air pump.
known good pump and recheck
contacted pump
coupler
or
fairing at
~
Does Not Operate
24P coupler.
•
Open circuit in main
•
Go to 'SYSTEM DOES NOT OPERATE" (page 12-4\ wire harness.
~.
Faul rela .
Pump does not operate.
-
g p
• Air leaking past air hose joints.
a
HOSES: Disconnect front and rear air hoses
Air Flow
HOSES: Check air pump inlet and pump to
under right fairing Check If air flows out
distributor air hoses for blockage or pinching.
lhrough each air hose jOint by operating air
pump.
Normal
Air Flows
SOLENOID VALVES: Check solenoid valve
I
operation (see page 1 2-1 9 to 12·201.
HOSE JOINTS: Reconnect
air
hoses to aJr
Air Leaks
hose Joints at air distributor Check front and
•
Loose hose Joints.
rear air hose joints for air leaks.
•
Damaged sealing material.
No Leaks
No
HOSES: Disconnect aJr hose trom each
Air Flow
suspension Check if air flows out through
•
Blocked or pinched air hose.
hoses.
•
Damaged air hose.
Air Flow
•
Air leakin from sus enslon.
Pump operates - LCD shows Increase, but system doesn't respond.
N
(cont'd)
12-11