Suzuki GSX-R750 Service Manual page 175

4-28 FI SYSTEM AND INTAKE AIR SYSTEM
CODE
c00 None
c11 Camshaft position sensor (CMP sensor)
c12 Crankshaft position sensor (CKP sensor)
c13 Intake air pressure sensor (IAP sensor)
c14 Throttle position sensor (TP sensor)
c15 Engine coolant temp. sensor (ECT sensor)
c21 Intake air temp. sensor (IAT sensor)
c22 Atmospheric pressure sensor (AP sensor)
c23 Tip over sensor (TO sensor)
c24 Ignition signal #1 (IG coil #1)
c25 Ignition signal #2 (IG coil #2)
c26 Ignition signal #3 (IG coil #3)
c27 Ignition signal #4 (IG coil #4)
c28 Secondary throttle valve actuator
c31 Gear position signal (GP switch)
c32 Injector signal #1 (FI #1)
c33 Injector signal #2 (FI #2)
c34 Injector signal #3 (FI #3)
c35 Injector signal #4 (FI #4)
c41 Fuel pump control system (FP control system)
c42 Ignition switch signal (IG switch signal)
In the LCD (DISPLAY) panel, the malfunction code is indicated from small code to large code.
*3
To get the proper signal from the throttle position sensor, the sensor basic position is indicated in the LCD
(DISPLAY) panel. The malfunction code is indicated in three digits. In front of the three digits, a line appears
in any of the position, upper, middle or lower line. If the indication is upper or lower line when engine rpm is
1 200 rpm, slightly turn the throttle position sensor and bring the line to middle.
In the normal condition, the throttle valve stop screw pushes throttle valves slightly, and indication point is
middle line.
Setting procedure:
1.Adjust the engine rpm to 1 200 rpm. ( 2-15)
2.Stop the engine and connect the special tool (Mode select
switch) to the dealer mode coupler at the wiring harness.
3.If the throttle position sensor adjustment is necessary, loosen
the screws and turn the throttle position sensor and bring the
line to middle.
4.Then, tighten the screws to fix the throttle position sensor.
[ 09930-11960: Torx wrench
← Incorrect
← Correct position
← Incorrect
The LCD indicates 0.4 sec./time, and two times show the cor-
rect position, where it is fixed.
MALFUNCTION PART REMARKS
No defective part
Pick-up coil signal, signal generator
*3
For #1 cylinder
For #2 cylinder
For #3 cylinder
For #4 cylinder
For #1 cylinder
For #2 cylinder
For #3 cylinder
For #4 cylinder
Fuel pump, Fuel pump relay
Anti-theft