Yamaha RX10LTGTYL Service Manual page 830

Item
Brake and parking brake
*Disc brake installation
Drive chain oil Drive chain oil
Drive chain
Skis and ski runners Skis and ski runners
Steering system Steering system
Lights
*Primary and secondary
clutches
*Steering column bearing
*Ski and front suspension
*Suspension component
*Parking brake cable end g
and lever end / throttle
cable end
Shroud latches
Fittings and fasteners
Tool kit and recommended
equipment
* It is recommended that these items be serviced by a Yamaha dealer.
NOTE:
Brake fluid replacement:
1. When disassembling the master cylinder or caliper cylinder, replace the brake fluid. Normally check
the brake fluid level and add the fluid as required.
2. On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years.
3. Replace the brake hoses every four years, or if cracked or damaged.
PERIODIC MAINTENANCE TABLE
Remarks
Check operation and fluid leakage.
*Adjust free play and/or replace pads if neces-
sary.
*Repair brake fluid.
Check for slight free play.
Lubricate shaft with specified grease as
required.
Check oil level.
*Replace.
Check deflection.
*Adjust if necessary.
Check for wear and damage.
*Repair if necessary.
Check operation.
*Adjust toe-out if necessary.
Check operation.
Replace bulbs if necessary.
Check engagement and shift s eed. Check engagement and shift speed
Adjust if necessary.
Inspect sheaves for wear / damage.
Inspect weights / rollers and bushings for
wear-for primary.
Inspect ramp shoes / bushings for wear-for
secondary.
Replace if necessary.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Check cable damage.
Replace if necessary.
Make sure that the shroud latches are hooked.
Check tightness.
*Replace if necessary.
Check for proper placement.
Preopera-
tion check
(Daily)
F
See NOTE.
Initial at 500 km (300 mi) and every
800 km (500 mi) thereafter.
F
F
F
Whenever operating elevation is
changed.
F
F
F
3
INSP
ADJ
Every
Initial
1 month
Seasonally
or
or
800 km
3,200 km
(500 mi)
(2,000 mi)
(40 hr)
(160 hr)
F
Every
1,600 km
(1,000 mi)
F
F
F
F
F
F
F
F
F
F
F
F