Toro Reelmaster 6500–D Service Manual page 230

Engine Starts, But Dies When Ignition Switch Is Released From Start Position
Cause
Run solenoid faulty.
Run solenoid wiring faulty.
Faulty high engine water temperature shut–down
switch (engine not overheated) or wiring.
Starter Cranks But Engine Will Not Start
Cause
Engine not cranking fast enough.
Run solenoid faulty.
Problem is not electrical.
Starter Cranks, But Should Not When Traction Pedal Is Depressed
Cause
Traction neutral switch circuit closed.
Electrical System
Correction
Replace run solenoid.
Repair wiring.
Check switch and wiring and replace or repair if
necessary.
Correction
Check battery and cable connections. Charge battery.
Replace battery if it won't hold accept a charge.
Repair wiring if necessary.
Replace run solenoid.
See Troubleshooting section of Chapter 3 – Engine.
Correction
Check traction neutral switch adjustment and adjust if
faulty.
Test traction neutral switch and replace if faulty.
Check traction neutral switch wiring and repair if faulty.
Page 5 – 30
Reelmaster 6500–D/6700–D