Toro Reelmaster 6500–D Service Manual page 22

REELMASTER 6500–D/6700–D Maintenance Schedule
Minimum Recommended Maintenance Intervals
Maintenance Procedure
Lubricate All Grease Fittings
Inspect Air Filter, Dust Cup, and Baffle
Check Battery Level/Cable Connections
} Change Engine Oil and Filter
Inspect Cooling System Hoses
{ Check Fan and Alternator Belt Tension
{ Torque Wheel Lug Nuts
~ Service Air Filter
Change Fuel Filter
Inspect Fuel Lines and Connections
} Check Engine RPM (idle and full throttle)
Check Rear Axle Oil Level (4wd)
Check Front Planetary Gear Lube
Inspect Engine Timing Belt (see note below)
Drain and Clean Fuel Tank
Change Hydraulic Oil
Change Hydraulic Oil Filter
= Change Front Planetary Gear Lube
Pack 2WD Rear Axle Bearings
Change Rear Axle Oil Level (4wd)
Check Rear Wheel Toe–In
{ Initial break in at 10 hours
} Initial break in at 50 hours
= Initial break in at 200 hours
~ If indicator shows red
Replace Moving Hoses
Replace Safety Switches
Cooling System Flush/Replace Fluid
NOTE: Replace Timing Belt if worn, cracked or oil soaked. A new Timing Belt should be installed
any time the Belt is removed or loosened.
Product Records and Manuals
Maintenance Interval & Service
Every
Every
100hrs
50hrs
A Level
Service
B Level
Service
Annual Recommendations:
Items listed are recommended every 1500
hours or 2 years, whichever occurs first.
Page 2 – 12 Rev. C
Every
Every
400hrs
200hrs
C Level
Service
D Level
Service
Reelmaster 6500–D/6700–D
Every
800hrs
E Level
Service