Club Car Precedent Villager 2 2019 Maintenance And Service Manual page 585

15-amp fuse..................................................... 12-16
16-pin connector .............................................. 12-28
4-pin connector ................................................ 12-32
batteries/voltage check ..................................... 12-13
battery pack voltage (under load) ...................... 12-14
charge indicator light ........................................ 12-31
charger interlock............................................... 12-22
charger receptacle............................................ 12-27
Forward/Reverse rocker switch ......................... 12-18
index of ........................................................... 12-12
key switch........................................................ 12-17
MCOR ............................................................. 12-23
MCOR limit switch ............................................ 12-17
motor, A1 and A2 voltage.................................. 12-26
pre-charge resistor ........................................... 12-20
reverse buzzer ................................................. 12-30
solenoid........................................................... 12-21
solenoid activating coil...................................... 12-20
solenoid diode.................................................. 12-20
speed sensor, motor ......................................... 12-25
Tow/Run switch ................................................ 12-15
test procedures, gasoline vehicle
4-pin connector ................................................ 18-31
accelerator pedal limit switch function ................ 18-12
battery ............................................................... 18-9
battery load test ............................................... 18-24
engine kill limit switch function........................... 18-13
fuel gauge........................................................ 18-29
fuel level sending unit ....................................... 18-27
fuel pump......................................................... 18-25
fuses ............................................................... 18-10
ground cables ...................................................18-11
hour meter ....................................................... 18-30
iignition spark................................................... 18-21
key switch
engine kill circuit (pedal-start) .........................18-11
starter circuit (pedal-start) ...............................18-11
low oil warning light .......................................... 18-23
maintenance/operate switch (pedal-start)........... 18-15
malfunction indicator light.................................. 18-23
multi-purpose buzzer ........................................ 18-22
multi-purpose buzzer limit switch ....................... 18-22
solenoid........................................................... 18-14
starter/generator..................................... 18-17–18-18
transacle limit switch......................................... 18-16
voltage regulator .............................................. 18-20
test procedures, index of
gasoline vehicle ................................................. 18-7
test procedures, motor
1 internal short circuits........................................ 16-2
2 armature circuit open ....................................... 16-2
3 field circuit open .............................................. 16-3
armature ground test .......................................... 16-9
testing
armature ground test (starter/generator) .............19-11
throttle body .......................................................... 21-1
throttle position sensor ...................................... 5-3, 5-5
tie rod and drag link
removal ............................................................... 7-9
tire
installation ........................................................... 8-3
removal ............................................................... 8-2
repair................................................................... 8-2
tools
see service tools ................................................ 24-3
torque converter
troubleshooting .................................................. 23-1
Tow/Run switch ..................................................... 12-3
installation ......................................................... 13-7
removal ............................................................. 13-7
testing ............................................................. 12-15
transaxle
installation ....................................................... 24-12
limit switch
lubrication .......................................................... 24-2
removal ............................................................. 24-9
service............................................................... 24-2
transaxle limit switch
testing ............................................................. 18-16
transaxle, type g
assembly ........................................................... 17-9
axle bearing ....................................................... 17-4
axle shaft
disassembly....................................................... 17-7
inspection .......................................................... 17-7
installation ....................................................... 17-10
lubrication .......................................................... 17-1
oil seal
removal ............................................................. 17-5
troubleshooting
CDT handheld programmer................................11-26
torque converter ................................................. 23-1
troubleshooting guide 1....................................... 12-6
troubleshooting guide 2....................................... 12-9
troubleshooting guide
gasoline vehicle ................................................. 18-2
U
usb port
installation ......................................................... 13-4
removal ............................................................. 13-3
usb receptacle
installation ....................................................... 19-36
removal ........................................................... 19-36
V
Visage
connector, 4-pin
2019 Precedent,Villager 2 and 4 Maintenance and Service Manual
installation .................................................... 19-27
removal ........................................................ 19-27
installation ...................................................... 17-4
removal .......................................................... 17-1
installation ...................................................... 17-4
removal .......................................................... 17-1
INDEX
Index-7