Maintenance - Club Car Precedent Villager 2 2019 Maintenance And Service Manual

PERIODIC MAINTENANCE
Gasoline Vehicles
• Accelerator: With the key switch in the ON position and the Forward/Neutral/Reverse switch in the FORWARD
position, as the accelerator pedal is pressed, the engine should start and the vehicle should accelerate smoothly to
full speed. When the pedal is released it should return to the original position. All Club Car vehicles operate at
reduced speed in reverse.
• Governor: Check maximum speed of the vehicle. The vehicle should operate at 12 to 15 mph (19 to 24 km/h)
on a level surface.
NOTE: The 12 to 15 mph (19 to 24 km/h) is for fleet golf cars. There is an optional 19 mph (30 km/h) speed kit available
for non-fleet golf cars, these vehicles should be set between 18.5 and 19.5 mph (29.7 and 31.3 km/h).

MAINTENANCE

See General Warnings on page 1-2.
To ensure trouble-free vehicle performance, it is very important to follow an established preventive maintenance
program. Regular and consistent vehicle maintenance can prevent vehicle downtime and expensive repairs that can
result from neglect. Use the Pre-Operation and Daily Safety Checklist beginning on page 10-2, the Performance
Inspection, and the following Periodic Service Schedules and Periodic Lubrication Schedules to keep the vehicle in
proper working condition.
Any vehicle not functioning correctly should be removed from use until it is properly repaired. This will prevent further
damage to the vehicle and avoid the possibility of injury due to unsafe conditions.
Contact your local Club Car distributor/dealer to perform all repairs and semiannual and annual periodic service.
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle until
repairs are made. Failure to make necessary repairs could result in fire, property damage, severe
personal injury, or death.
• Only trained technicians should service or repair the vehicle or battery charger. Anyone doing even
simple repairs or service should have knowledge and experience in electrical and mechanical repair.
The appropriate instructions must be used when performing maintenance, service, or accessory
installation.
Electric vehicles:
• Hot! Do not attempt to service hot motor. Attempting to do so could cause severe burns.
• To avoid unintentionally starting the vehicle, disconnect the batteries and discharge the controller.
See Disconnect the Batteries – Electric Vehicles on page 1-4.
Gasoline vehicles:
• Moving parts: Do not attempt to service gasoline vehicle while the engine is running.
• Hot! Do not attempt to service hot engine or exhaust system. Failure to heed this warning could
result in severe burns.
• To avoid unintentionally starting the vehicle, disconnect battery and spark plug wire(s).
See Disconnect the Battery - Gasoline Vehicles on page 1-3.
WARNING CONTINUED ON NEXT PAGE
2019 Precedent,Villager 2 and 4 Maintenance and Service Manual
10
Maintenance
Page 10-3