Check and lubricate all components at the intervals listed in the periodic
maintenance chart below. Items not listed in the chart should be lubricated in the
general lubrication interval. The rocker arm is lubricated at the factory and does
not require additional lubrication. However, if these components are used in severe
conditions, the user may perform additional lubrication as required.
Project
Recommended model
Engine oil
SAE10W-40/SJ or Higher
Front
SAE 75/80W-90 GL5
Diff erential
Rear
SAE 75/80W-90 GL5
Diff erential
Coolant
Brake fl uid
DOT4
Suspension,
balance bar
grease
Front Fluid Reservoir Cover and Electrical
Maintenance Cover
LUBRICATING OIL
Capacity
3 qts. (3300 ml)
0.16 qts. (180 mL )
1.36 qts. (1500 ml)
8.63 qts. (9500 ml)
——
4-4
Inspection procedure
Maintain level in safe
range on dipstick
Drive each
2000km Kilometers.
Maintain the level
between the fi ll lines.
Maintain the level
between the fi ll lines.
Grease nozzle
( 2 Pump max) per 500
mile.
There are two snap-type
removable cover plates
located in the front of the
vehicle. The fuse box is
located under the electrical
service cover and the brake
fluid reservoir is located
under the front cover.
1
Front fluid cover
2
Electrical service cover