Front/Rear Gearbox (Demand Drive) Fluid - Segway Villain SX10 Owner's Manual

FRONT/REAR GEARBOX (DEMAND DRIVE) FLUID

Check and replace the demand drive fluid at intervals in the periodic maintenance
chart.Replace the front gearbox fluid every 25 hours if the 4WD unit is exposed to
extreme use.Extreme use includes any of the following:
• Continuous 4WD operations running
• In mountain or mountain areas for long periods of time in 4WD mode
• 4WD is the primary mode of all-wheel drive operations
If the front gearbox makes too much noise during 4WD
operation, change the demand drive fluid. If the noise
Use the recommended oil type. The use of other oil may result in improper
operation.
Check the Rear Gear Box Oil Level
1. Park the vehicle on the level ground. If the engine is warm, wait at least five
minutes to allow the oil to flow back into the bottom of the engine.
2. With a rag, remove and pull out the oil dipstick.
3. Clean the dipstick.
4. Re-insert the dipstick completely.
5. Check the oil level as shown in the figure above. The oil should be in the
gradient marks. If not, add if the oil level is low.
6. Wipe the dipstick before reinstalling.
!
CAUTION
continues, see your Segway dealer.
4-12