Safety Instructions; Before Operating; While Operating - Toro Multi Pro 5800 Service Manual

Safety Instructions

The Multi Pro 5800 Turf Sprayer is designed and tested
to offer safe service when operated and maintained
properly. Although hazard control and accident preven-
tion are partially dependent upon the design and config-
uration of the machine, these factors are also
dependent upon the awareness, concern and proper
training of the personnel involved in the operation, trans-
port, maintenance and storage of the machine. Improp-
er use or maintenance of the machine can result in injury

Before Operating

1. Read and understand the contents of the Operator's
Manual before starting and operating the machine. Be-
come familiar with the controls and know how to stop the
machine and engine quickly. Additional copies of the
Operator's Manual are available on the internet at
www.Toro.com.
2. Keep all shields, safety devices and decals in place.
If a shield, safety device or decal is defective, illegible
or damaged, repair or replace it before operating the
machine. Also tighten any loose nuts, bolts or screws to
ensure machine is in safe operating condition.
3. Assure interlock switches are adjusted correctly so
engine cannot be started unless traction pedal is in the
NEUTRAL position.

While Operating

1. Sit on the seat when starting and operating the ma-
chine.
2. Before starting the engine:
A. Engage the parking brake.
B. Make sure traction pedal is in the NEUTRAL posi-
tion and the pump switch is OFF.
3. Do not run engine in a confined area without ade-
quate ventilation. Exhaust fumes are hazardous and
could possibly be deadly.
4. Do not touch engine, radiator, muffler or exhaust
pipe while engine is running or soon after it is stopped.
These areas could be hot enough to cause burns.
Safety
or death. To reduce the potential for injury or death,
comply with the following safety instructions.
To reduce the potential for injury or death, com-
ply with the following safety instructions.
4. Since diesel fuel is flammable, handle it carefully:
A. Store fuel in containers specifically designed for
this purpose.
B. Do not remove machine fuel tank cap while en-
gine is hot or running.
C. Do not smoke while handling fuel.
D. Fill fuel tank outdoors and only to within an inch of
the top of the tank, not the filler neck. Do not overfill
the fuel tank.
E. Wipe up any spilled fuel.
5. Before getting off the seat:
A. Ensure that traction pedal is in the NEUTRAL
position.
B. Set parking brake.
C. Turn pump switch OFF.
D. Stop engine and remove key from ignition switch.
E. Do not park on slopes unless wheels are chocked
or blocked.
6. Follow spray chemical manufacturer's recommen-
dations for handling precautions, protective equipment
and mixing proportions.
Page 1 - - 2
WARNING
Multi Pro 5800