Battery; Brakes - APRILIA pegaso 650 i.e. Service Manual

REPAIR INFORMATION

8.1.3 BATTERY

DEFECT
Battery runs down too
quickly
Battery polarity inverted

8.1.4 BRAKES

DEFECT
Poor braking power
Brakes squeak
Excessive stroke of
brake lever
Brake fluid leakage
8 - 8
- 00
SYMPTOM AND POSSIBLE CAUSES
Recharging system defective
Battery elements have lost much active potential consequent
on excessive charge
Presence of short circuits inside battery owing to excessive
accumulation of sediments
Old battery
Battery has been incorrectly connected to the system
SYMPTOM AND POSSIBLE CAUSES
Brake fluid leakage from hydraulic system
Brake pads worn
Contact surfaces of pads soiled by oil, grease or brake
fluid
Brake discs worn
Air in hydraulic circuit
Brake discs dirty with oil, grease or brake fluid
Foreign matter in brake fluid
Brake pump return hole clogged
Pad contact surfaces hardened
Pads installed backwards
Wheel bearing damaged
Front or rear wheel pin loose
Brake pads worn
Air in hydraulic circuit
Insufficient brake fluid
Unsuitable brake fluid
Brake caliper pins locked
Insufficient tightening of connection fittings
Cracked pipes
Pumping element and/or body worn
Pegaso 650 I.E.
REMEDY
Check the alternator, the
regulator/rectifier, the
circuit connections and
carry out operations
necessary to restore
correct recharge
Change the battery and
repair charging system
Change the battery
Change the battery
Change the battery and
make sure new one is
connected properly
REMEDY
Repair or replace
Change pads
Change pads
Change disc
Bleed the circuit
Clean
Change brake fluid
Disassemble and clean brake
pump
Restore surfaces with sandpaper
Install correctly
Replace
Tighten to prescribed driving
torque
Replace
Bleed the circuit
Replace
Replace
Disassemble and clean
Tighten to prescribed driving
torque
Replace
Change the pumping element
and/or body
Release 00/2002-02