Suzuki SFV650 Service Manual page 38

0B-12 Maintenance and Lubrication:
Throttle Cable Play Inspection and Adjustment
Inspect throttle cable play
Initially at 1 000 km (6 000 miles, 2 months) and
every 6 000 km (4 000 miles, 12 months) thereafter
Inspect and adjust the throttle cable play "a" as follows.
Throttle cable play "a"
2.0 – 4.0 mm (0.08 – 0.16 in)
1) Remove the rubber boot (1).
2) Loosen the lock-nut (2) of the throttle pulling cable
(3).
3) Turn the adjuster (4) in or out until the throttle cable
play "a" (at the throttle grip) is between 2 – 4 mm
(0.08 – 0.16 in).
4) Tighten the lock-nut (2) while holding the adjuster
(4).
1
5) Install the rubber boot (1) firmly.
WARNING
!
After the adjustment is completed, check that
handlebar movement does not raise the
engine idle speed and that the throttle grip
returns smoothly and automatically.
B944H10206009
" a "
I944H1020028-01
2
3
4
I944H1020029-05
Throttle Valve Synchronization
Inspect throttle valve synchronization
Initially 1 000 km (600 miles, 2 months) (E-33 only)
and every 12 000 km (7 500 miles, 24 months)
Inspect the throttle valve synchronization periodically.
Refer to "Throttle Valve Synchronization in Section 1D
(Page 1D-15)".
Cooling System Inspection
Inspect cooling system
Every 6 000 km (4 000 miles, 6 months)
Replace engine coolant
Every 2 years
Engine Coolant Level Inspection
1) Keep the motorcycle upright.
2) Remove the left frame cover. Refer to "Exterior Parts
Removal and Installation in Section 9D (Page 9D-
4)".
3) Check the engine coolant level by observing the full
and lower lines on the engine coolant reservoir tank.
If the level is below the lower line, add engine
coolant to the full line from the engine coolant
reservoir tank filler cap.
F F
4) After finishing the engine coolant level inspection,
reinstall the fuel tank and left frame cover. Refer
"Fuel Tank Removal and Installation in Section 1G
(Page 1G-7)" and "Exterior Parts Removal and
Installation in Section 9D (Page 9D-4)".
Engine Coolant Change
Refer to "Engine Coolant Description in Section 1F
(Page 1F-1)".
B944H10206010
B944H10206012
L L
I944H1020030-01