Dodge 2000 DURANGO Service Manual page 1044

6 INDEX
Description
FAN RELAY—PCM OUTPUT, RADIATOR
COOLING . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-38
FASCIA, FRONT BUMPER . . . . . . . . . . . . . . . 13-2
FASCIA, REAR BUMPER . . . . . . . . . . . . . . . . 13-3
FASTENER IDENTIFICATION . . . . . . . . . . . Intro.-3
FASTENER USAGE . . . . . . . . . . . . . . . . . . . Intro.-6
FEED (TCM), BATTERY . . . . . . . . . . . . . . . 21-349
FENDER, LEFT FRONT . . . . . . . . . . . . . . . . . 23-26
FENDER, RIGHT FRONT . . . . . . . . . . . . . . . . 23-26
FILL LEVEL, LUBRICANT . . . . . . . . 21-417,21-444
FILL PROCEDURE, TRANSMISSION
FILLER DOOR, FUEL . . . . . . . . . . . . . . . . . . 23-47
FILLER TUBE CAP, FUEL TANK . . . . . . 14-22,14-5
FILLING, COOLING SYSTEM—DRAINING
FILTER, FUEL PUMP INLET . . . . . . . . . . . . . 14-16
FILTER REPLACEMENT, FLUID . . . 21-224,21-357,
FILTER-DRIER . . . . . . . . . . . . . . . . . . . 24-52,24-6
FILTER/FUEL PRESSURE REGULATOR,
FUEL . . . . . . . . . . . . . . . . . . . . . . . . . . 14-14,14-3
FINAL ASSEMBLY . . . . . . . . . . . . . . . . . 3-46,3-81
FINESSE SANDING, BUFFING, AND
POLISHING . . . . . . . . . . . . . . . . . . . . . . . . . . 23-2
FINISH, BASE COAT/CLEAR COAT
FIRING ORDER—4.7L V-8 ENGINE,
ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-21
FIRING ORDER—5.2L/5.9L V-8 ENGINES,
ENGINE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-21
FITTINGS, QUICK-CONNECT . . . . . . . . 14-11,14-6
FIVE VOLT SENSOR SUPPLIES—
PRIMARY AND SECONDARY . . . . . . . . . . . . 14-32
FLARING, BRAKE TUBE . . . . . . . . . . . . . . . . . 5-12
FLASHER, COMBINATION . . . . . . . . . . . 8J-3,8J-5
FLEXPLATE . . . . . . . . . . . . . . . . . . . . . . . . . . 9-69
FLOOR CARGO STORAGE DOOR . . . . . . . . . 23-64
FLOOR CARPET . . . . . . . . . . . . . . . . . . . . . . 23-63
FLOOR CONSOLE . . . . . . . . . . . . . . . . . . . . 23-62
FLOW AND PRESSURE, POWER
STEERING . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-4
FLOW CHECK PROCEDURE, THROTTLE
BODY MINIMUM AIR . . . . . . . . . . . . . . . . . . 14-43
FLOW CHECK, RADIATOR COOLANT . . . . . . . 7-16
FLUID . . . . . . . . . . . . . . . . . . 21-169,21-332,21-8
FLUID AND FILTER REPLACEMENT
FLUID, BRAKE . . . . . . . . . . . . . . . . . . . . . . . . 5-30
FLUID CAPACITIES . . . . . . . . . . . . . . . . . . . . . 0-2
FLUID, CAUSES OF BURNT . 21-206,21-352,21-44
FLUID CONTAMINATION . . . 21-206,21-352,21-44
FLUID CONTAMINATION, BRAKE . . . . . . . . . . 5-10
FLUID LEAK DIAGNOSIS, CONVERTER
HOUSING . . . . . . . . . . . . . . . 21-211,21-356,21-50
FLUID LEVEL, BRAKE . . . . . . . . . . . . . . . . . . 5-11
FLUID LEVEL CHECK . . . . . . 21-224,21-356,21-60
FLUID LEVEL, EFFECTS OF INCORRECT . . 21-206,
FLUID LEVEL SENSOR, WASHER
FLUSH MEASUREMENTS, BODY GAP
FLUSHING COOLERS AND TUBES
FLUSHING, COOLING SYSTEM—
CLEANING/REVERSE . . . . . . . . . . . . . . . . . . . 7-24
FOG LAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-16
FOG LAMP ALIGNMENT . . . . . . . . . . . . . . . . 8L-8
FOG LAMP BULB . . . . . . . . . . . . . . . . . . . . . 8L-10
FORM-IN-PLACE GASKETS . . . . . 9-149,9-15,9-91
FOUR WHEEL ANTILOCK BRAKES
FOUR-WHEEL-DRIVE VEHICLE TOWING
FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-5
FRAME, 3RD ROW SEAT CUSHION . . . . . . . 23-16
FRAME DIMENSIONS . . . . . . . . . . . . . . . . . . 13-8
FRAME SERVICE . . . . . . . . . . . . . . . . . . . . . . 13-5
FREQUENCY INTERFERENCE, RADIO
FRONT AXLE . . . . . . . . . . . . . . . . . . . . . . . . . 3-35
FRONT AXLE DRIVESHAFTS
. . . . . . . . . . . . . 3-18
FRONT AXLE SKID PLATE
. . . . . . . . . . . . . . . 13-6
FRONT BAND ADJUSTMENT
. . . . . . . . . . . 21-310
FRONT BEARING, OUTPUT SHAFT
FRONT BUMPER
. . . . . . . . . . . . . . . . . . . . . . 13-1
FRONT BUMPER FASCIA . . . . . . . . . . . . . . . . 13-2
FRONT BUMPER INNER BRACKET
FRONT CLUTCH
. . 21-109,21-138,21-197,21-276,
FRONT DISC BRAKES
. . . . . . . . . . . . . . . . . . . 5-4
FRONT DOOR
. . . . . . . . . . . . . . . . . . . . . . . 23-32
FRONT DOOR GLASS
. . . . . . . . . . . . . . . . . 23-36
Group-Page Description
FRONT DOOR GLASS RUN
WEATHERSTRIP . . . . . . . . . . . . . . . . . . . . . 23-38
FRONT DOOR HINGE . . . . . . . . . . . . . . . . . . 23-33
FRONT DOOR INNER BELT
WEATHERSTRIP . . . . . . . . . . . . . . . . . . . . . 23-36
FRONT DOOR INSIDE HANDLE
ACTUATOR . . . . . . . . . . . . . . . . . . . . . . . . . . 23-35
FRONT DOOR LATCH . . . . . . . . . . . . . . . . . . 23-35
FRONT DOOR LATCH STRIKER
FRONT DOOR LOCK CYLINDER . . . . . . . . . . 23-33
. . . . . 21-225, FRONT DOOR LOWER GLASS RUN
21-358,21-61 CHANNELS . . . . . . . . . . . . . . . . . . . . . . . . . 23-37
FRONT DOOR OPENING WEATHERSTRIP
FRONT DOOR OUTER BELT
. . . 7-23 WEATHERSTRIP . . . . . . . . . . . . . . . . . . . . . 23-36
FRONT DOOR OUTSIDE HANDLE
FRONT DOOR SECONDARY SEAL
21-60 FRONT DOOR TRIM PANEL . . . . . . . . . . . . . 23-31
FRONT DOOR WATERDAM
FRONT DOOR WINDOW REGULATOR
FRONT DRIVESHAFT
FRONT FENDER, LEFT
FRONT FENDER, RIGHT . . . . . . . . . . . . . . . . 23-26
FRONT LIGHTING, 8W-50
. . . . . . . . . 23-2 FRONT MOUNTS, ENGINE
FRONT OUTPUT SHAFT SEAL
FRONT PARK BRAKE CABLE
FRONT PROPELLER SHAFT . . . . . . . . . . . . . . . . 3-8
FRONT SEAL, OIL PUMP . . . . . . . . . . . . . . 21-365
FRONT SEAT BELT BUCKLE . . . . . . . . . . . . . 23-57
FRONT SEAT BELT RETRACTOR
FRONT SERVO . . . . . . . . . . . . . . . . 21-138,21-306
FRONT SERVO PISTON
FRONT SIDE MARKER LAMP BULB
FRONT SUSPENSION
FRONT SUSPENSION - 4X2 . . . . . . . . . . . . . . . 2-6
FRONT SUSPENSION - 4X4 . . . . . . . . . . . . . . 2-14
FRONT WHEEL SPEED SENSOR - 4X2
FRONT WHEEL SPEED SENSOR - 4X4
FRONT WHEELHOUSE LINER
FUEL DELIVERY SYSTEM
FUEL FILLER DOOR . . . . . . . . . . . . . . . . . . . 23-47
FUEL FILTER/FUEL PRESSURE
REGULATOR . . . . . . . . . . . . . . . . . . . . 14-14,14-3
. . . . . 21-224, FUEL GAUGE SENDING UNIT
21-357,21-60 FUEL INJECTION SYSTEM . . . . . . . . . . . . . . 14-27
FUEL INJECTOR RAIL—3.9/5.2/5.9L
ENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-17
FUEL INJECTOR RAIL—4.7L ENGINE
FUEL INJECTOR RAIL—4.7L V–8 ENGINE
FUEL INJECTOR TEST
FUEL INJECTOR(S)
FUEL INJECTORS
FUEL INJECTORS—PCM OUTPUT . . . . . . . . 14-37
FUEL LEVEL SENSOR—PCM INPUT
FUEL PRESSURE LEAK DOWN TEST
21-352,21-44 FUEL PUMP . . . . . . . . . . . . . . . . . . . . . . . . . . 14-2
. . . . . . . . . 8K-5 FUEL PUMP AMPERAGE TEST
. . . . 23-117 FUEL PUMP CAPACITY TEST
. . . . . . 21-226, FUEL PUMP INLET FILTER
21-359,21-62 FUEL PUMP MODULE
FUEL PUMP PRESSURE TEST . . . . . . . . . . . . 14-6
FUEL PUMP RELAY
FUEL PUMP RELAY-PCM OUTPUT
FUEL PUMP RELAYS, ASD
FUEL RAIL—3.9/5.2/5.9L ENGINES . . . . . . . . 14-5
FUEL REQUIREMENTS . . . . . . . . . . . . . . . . . 14-24
. . . . . . . . 5-40 FUEL SYSTEM
. . . . 0-10 FUEL SYSTEM PRESSURE
FUEL SYSTEM PRESSURE RELEASE
PROCEDURE . . . . . . . . . . . . . . . . . . . . . . . . 14-10
FUEL TANK
FUEL TANK CAPACITY . . . . . . . . . . . . . . . . . 14-24
FUEL TANK FILLER TUBE CAP
. . . . . . 8F-9
FUEL TANK SKID PLATE—4WD
VEHICLES . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-7
FUEL TUBES/LINES/HOSES AND CLAMPS
FUEL/IGNITION SYSTEMS, 8W-30
FUNCTION HIGH PRESSURE SWITCH/
. 21-237,21-73
HIGH PRESSURE CUT-OFF SWITCH,
DUAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-22
FUNCTIONS, CIRCUIT . . . . . . . . . . . . . . . . . . 8W-4
FUSE BLOCK, RELAY
. . . . . . . . 13-2
FUSE, GENERATOR CARTRIDGE . . . . . . 8O-2,8O-6
21-307,21-34
FUSE, IGNITION-OFF DRAW
FUSE/RELAY BLOCK, 8W-11
GAP AND FLUSH MEASUREMENTS,
BODY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-117
Group-Page
. . . . . . . . . . 23-35
. . 23-38
. . . . . . . . 23-33
. . . . . . . . 23-38
. . . . . . . . . . . . . 23-31
. . . . . 23-37
. . . . . . . . . . . . . . . . . . . 3-20
. . . . . . . . . . . . . . . . . 23-26
. . . . . . . . . . . . . . 8W-1
. . . . . . . . . . . . . . 9-158
. . . . 21-419,21-446
. . . . . . . . . . . . . 5-21
. . . . . . . . . 23-56
. . . . . . . . . 21-105,21-272
. . . . . . 8L-11
. . . . . . . . . . . . . . 2-13,2-22
. . . . . 5-45
. . . . . 5-46
. . . . . . . . . . . 23-25
. . . . . . . . . . . 14-1,14-2
. . . 14-16,14-3,14-9
. . . . . . 14-5
. 14-19
. . . . . . . . . . . . . . . . . 14-10
. . . . . . . . . . . . . . . . . . . 14-20
. . . . . . . . . . . . . . . . . . . . . 14-4
. . . . . . 14-32
. . . . . . 14-7
. . . . . . . . . . . 14-8
. . . . . . . . . . . . 14-7
. . . . . . . . . . . . . 14-16
. . . . . . . . . . . . . 14-15,14-2
. . . . . . . . . . . . . . . . . . . 14-44
. . . . . . . 14-37
. . . . . . . . . . . . . 14-42
. . . . . . . . . . . . . . . . . . . . . . . 14-54
. . . . . . . . . . . . . 14-24
. . . . . . . . . . . . . . . . . . . . . 14-20,14-4
. . . . . . 14-22,14-5
. . 14-6
. . . . . . . . 8W-1
. . . . . . . . . . . . . . 8O-4,8O-8
. . . . . . . . . 8O-3,8O-7
. . . . . . . . . . . . 8W-1
Description
GARAGE DOOR OPENER STORAGE BIN
GARAGE DOOR OPENER STORAGE BIN
DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8V-13
GASKET, CYLINDER HEAD COVER
GASKET FAILURE DIAGNOSIS, CYLINDER
HEAD . . . . . . . . . . . . . . . . . . . . . . . . . . 9-12,9-146
GASKETS, FORM-IN-PLACE . . . . 9-149,9-15,9-91
GAUGE SENDING UNIT, FUEL . . . 14-16,14-3,14-9
GAUGES, PRESSURE . . . . . . . . . . . . . . . . . . . 22-3
GEAR - 4X2, RACK & PINION STEERING
GEAR - 4X4, RACK & PINION STEERING
GEAR AND EXCITER RING, RING
GEAR BACKLASH, DIFFERENTIAL
BEARING PRELOAD . . . . . . . . . . . . . . . . 3-50,3-95
GEAR CLEARANCE, SIDE . . . . . . . . . . . . . . . . 3-96
GEAR CONTACT PATTERN ANALYSIS
GEAR DEPTH, 8 1/4 AXLE PINION
GEAR DEPTH, 9 1/4 AXLE PINION
GEAR DEPTH, PINION . . . . . . . . . . . . . . . . . . 3-48
GEAR NOISE . . . . . . . . . . . . . . . . . . . . . 3-34,3-67
GEAR, PINION . . . . . . . . . . . . . . . . . . . . 3-41,3-76
GEAR, RACK & PINION STEERING
GEAR, RING . . . . . . . . . . . . . . . . . . . . . . . . . . 3-40
GEAR SELECTOR INDICATOR . . . . . . . 8E-17,8E-5
GEAR SET, PLANETARY . . . . . . . . . . . . . . . 21-387
GEAR SHIFT LEVER . . . . . . . . . . . . . . . . . . . 19-18
GEARSET, PLANETARY . . . . . . . . . . . . 21-200,21-38
GEARSHIFT CABLE . . . . . . 21-141,21-208,21-231,
21-309,21-353,21-366,21-392,21-45,21-66
GEARSHIFT MECHANISM . . 21-202,21-344,21-40
GEARTRAIN, PLANETARY . 21-139,21-343,21-392
GEARTRAIN/OUTPUT SHAFT,
PLANETARY . . . . . . . . . . . . 21-114,21-282,21-307
GENERAL DIAGNOSIS, 45RFE
AUTOMATIC TRANSMISSION . . . . . . . . . . 21-353
GENERAL INFORMATION . . . . . . . . . . . . 3-31,3-65
GENERAL INFORMATION, 8W-01 . . . . . . . . . 8W-1
GENERATOR . . . . . . . . . . . . . . . . . . . . . 8C-1,8C-3
GENERATOR CARTRIDGE FUSE
GENERATOR RATINGS . . . . . . . . . . . . . . . . . 8C-5
GLASS, FRONT DOOR . . . . . . . . . . . . . . . . . 23-36
GLASS HEATING GRID, REAR . . . . . . . 8N-2,8N-3
GLASS HEATING GRID REPAIR, REAR
GLASS, QUARTER WINDOW . . . . . . . . . . . . . 23-8
GLASS, REAR DOOR . . . . . . . . . . . . . . . . . . 23-44
GLASS, REAR DOOR STATIONARY
GLASS RUN CHANNELS, FRONT DOOR
LOWER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-37
GLASS RUN CHANNELS, REAR DOOR
GLASS RUN WEATHERSTRIP, FRONT
DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-38
GLASS RUN WEATHERSTRIP, REAR
DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-43
GLASS, STATIONARY . . . . . . . . . . . . . . . . . . 23-5
GLOVE BOX . . . . . . . . . . . . . . . . . . . . . . . . . 8E-24
GLOVE BOX COMPONENTS . . . . . . . . . . . . . 8E-25
GLOVE BOX LAMP AND SWITCH
GLOVE BOX LATCH STRIKER . . . . . . . . . . . 8E-23
GOVERNOR, ELECTRONIC . . . . . . . . 21-204,21-41
GOVERNOR PRESSURE CURVES
GOVERNOR SOLENOID AND PRESSURE
SENSOR . . . . . . . . . . . . . . . . . . . . . 21-231,21-68
GRAB HANDLE, A-PILLAR . . . . . . . . . . . . . . 23-52
GRID, OUTSIDE MIRROR HEATING
GRID, REAR GLASS HEATING . . . . . . . 8N-2,8N-3
GRID REPAIR, REAR GLASS HEATING
GRILLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-21
GRILLE, COWL . . . . . . . . . . . . . . . . . . . . . . 23-24
GROUND DISTRIBUTION, 8W-15 . . . . . . . . . 8W-1
GROUND—PCM INPUT, SIGNAL . . . . . . . . . 14-36
GROUNDS, POWER . . . . . . . . . . . . . . . . . . . 14-35
GUIDES, VALVE . . . . . . . . . . . . . . . . . . . . . . . . 9-5
HANDLE ACTUATOR, FRONT DOOR
INSIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-35
HANDLE ACTUATOR, REAR DOOR
INSIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-42
HANDLE, A-PILLAR GRAB . . . . . . . . . . . . . . 23-52
HANDLE, FRONT DOOR OUTSIDE
HANDLE, LIFTGATE OUTSIDE . . . . . . . . . . . 23-49
HANDLE, OVERHEAD ASSIST . . . . . . . . . . . 23-65
HANDLE, PARK BRAKE RELEASE
HANDLE, REAR DOOR OUTSIDE
HAZARD WARNING SWITCH, TURN
SIGNAL SWITCH . . . . . . . . . . . . . . 8J-2,8J-5,8J-6
HAZARD WARNING SYSTEM . . . . . . . . . . . . . 8J-1
HAZARD WARNING SYSTEMS, TURN
SIGNAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8J-4
HEAD ASSEMBLY, CYLINDER
. . . . . . 9-124,9-182
DN
Group-Page
. . . . 8V-3
. . . 9-140,9-90
. . 19-12
. . 19-12
. . . . . . . . . 3-75
. . 3-53,3-96
. . . . . . . . 3-91
. . . . . . . . 3-92
. . 19-11,19-14
. . . . . . 8O-2,8O-6
. . . . . 8N-4
. . . . . . . . 23-7
. . . . 23-44
. . . . . . . . 8E-23
. . 21-205,21-43
. . . . . . . 8N-2
. . . . . 8N-4
. . . . . . . . 23-33
. . . . . . . . 8E-18
. . . . . . . . . 23-40