Dodge 2000 DURANGO Service Manual page 1041

DN
Description
CENTER SUPPORT BRACKET,
INSTRUMENT PANEL . . . . . . . . . . . . . . . . . . 8E-20
CENTERING, CLOCKSPRING . . . . . . . . . . . . 8M-14
CENTRAL TIMER MODULE; CHIME/
BUZZER WARNING SYSTEMS . . . . . . . 8U-1,8U-3
CENTRAL TIMER MODULE; INSTRUMENT
PANEL SYSTEMS . . . . . . . . . . . . . . . . 8E-26,8E-4
CENTRAL TIMER MODULE; POWER
LOCK SYSTEMS . . . . . . . . . . . . . . . . . . 8P-2,8P-6
CENTRAL TIMER MODULE; VEHICLE
THEFT/SECURITY SYSTEMS . . . . . . . . . . . . . 8Q-2
CENTRAL TIMER MODULE; WIPER AND
WASHER SYSTEMS . . . . . . . . . . . . . . . . . . . . 8K-4
CENTRAL TIMER MODULE, 8W-45
CERTIFICATION LABEL, VEHICLE SAFETY . Intro.-2
CHAIN AND SPROCKETS, TIMING
CHAIN COVER, TIMING . . . . . . . 9-110,9-169,9-48
CHAIN STRETCH, MEASURING TIMING
CHAIN, TIMING . . . . . . . . . . . . . . . . . 9-111,9-170
CHAIN—MEASURING WEAR, TIMING . . . . . . 9-22
CHANGE, LUBRICANT . . . . . . . . . . . . . . 3-35,3-69
CHANNELS, FRONT DOOR LOWER
GLASS RUN . . . . . . . . . . . . . . . . . . . . . . . . . 23-37
CHANNELS, REAR DOOR GLASS RUN
CHARGE, REFRIGERANT SYSTEM . . . . . . . . 24-28
CHARGING, BATTERY . . . . . . . . . . . . . . . . . 8A-16
CHARGING SYSTEM . . . . . . . . . . . . . . . 8C-1,8C-2
CHARGING SYSTEM, 8W-20 . . . . . . . . . . . . 8W-1
CHARGING SYSTEM, ON-BOARD
DIAGNOSTIC TEST . . . . . . . . . . . . . . . . . . . . 8C-3
CHART, TORQUE; BRAKES . . . . . . 5-31,5-39,5-47
CHART, TORQUE; CHARGING SYSTEM . . . . . 8C-5
CHART, TORQUE; EMISSION CONTROL
SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . 25-34
CHART, TORQUE; FUEL SYSTEM . . . . 14-26,14-54
CHART, TORQUE; IGNITION SYSTEM
CHART, TORQUE; SPEED CONTROL
SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8H-9
CHART, TORQUE; STEERING . . . 19-14,19-19,19-9
CHART, TORQUE; SUSPENSION
CHART, TORQUE; TIRES AND WHEELS . . . . 22-11
CHARTS—RE TRANSMISSION,
DIAGNOSIS TABLES . . . . . . . . . . . . 21-213,21-51
CHECK, COOLANT LEVEL . . . . . . . . . . . . . . . 7-23
CHECK, COOLANT—ROUTINE LEVEL
CHECK, FLUID LEVEL . . . . . 21-224,21-356,21-60
CHECK, OIL PUMP VOLUME . . . . 21-226,21-358,
CHECK PROCEDURE, THROTTLE BODY
MINIMUM AIR FLOW . . . . . . . . . . . . . . . . . 14-43
CHECK, RADIATOR CAP-TO-FILLER NECK
SEAL—PRESSURE RELIEF . . . . . . . . . . . . . . 7-21
CHECK, RADIATOR COOLANT FLOW . . . . . . . 7-16
CHECK VALVE SERVICE, CONVERTER
DRAINBACK . . . . . . . . . . . . . . . . . . . 21-225,21-62
CHECK VALVE, VACUUM . . . . . . . . . . 24-11,24-70
CHECKING ENGINE OIL PRESSURE
CHECKS, PRELIMINARY . . . . . . . . . . . . . . . . 7-10
CHIME WARNING SYSTEM . . . . . . . . . . . . . . 8U-1
CHIME WARNING SYSTEM SWITCHES
CIGAR LIGHTER AND POWER OUTLET,
INSTRUMENT PANEL . . . . . . . . . . . . . . . . . . 8E-22
CIGAR LIGHTER, INSTRUMENT PANEL
CIRCUIT ACTUATION TEST MODE . . . . . . . . . 25-2
CIRCUIT BREAKER . . . . . . . . . . . . . . . . 8S-2,8S-3
CIRCUIT FUNCTIONS . . . . . . . . . . . . . . . . . . 8W-4
CIRCUIT INFORMATION . . . . . . . . . . . . . . . . 8W-4
CIRCUIT SENSE—PCM INPUT, IGNITION
CIRCUITS, NON-MONITORED . . . . . . . . . . . 25-22
CIRCUITS, SPEED CONTROL SOLENOID
CIRCUITS-PCM OUTPUTS, CCD BUS (+/-)
CLAMPS, FUEL TUBES/LINES/HOSES
CLAMPS, HOSE . . . . . . . . . . . . . . . . . . . . . . . . 7-8
CLASSIFICATION OF LUBRICANTS
CLEANER ELEMENT (FILTER), AIR
CLEANING TIRES . . . . . . . . . . . . . . . . . . . . . . 22-6
CLEARANCE, SIDE GEAR . . . . . . . . . . . . . . . . 3-96
CLOCKSPRING . . . . . . . . . . . . . . . . . 8M-13,8M-4
CLOCKSPRING CENTERING . . . . . . . . . . . . 8M-14
CLUNKING NOISE DURING
ACCELERATION . . . . . . . . . . . . . . . . . . . . . . . 3-18
CLUSTER, 8W-40 INSTRUMENT
CLUSTER BEZEL . . . . . . . . . . . . . . . . . . . . . 8E-12
CLUSTER COMPONENTS, INSTRUMENT . . . 8E-14
CLUSTER, INSTRUMENT; CHIME/BUZZER
WARNING SYSTEMS . . . . . . . . . . . . . . 8U-2,8U-5
Group-Page Description
CLUSTER, INSTRUMENT; INSTRUMENT
PANEL SYSTEMS . . . . . . . . . . . . 8E-13,8E-2,8E-6
CLUTCH AND BAND OPERATION, AIR
TESTING TRANSMISSION . . . . . . . . 21-211,21-49
CLUTCH ASSEMBLY, INPUT
CLUTCH ASSEMBLY, LOW/REVERSE . . . . . 21-391
CLUTCH CAM/OVERDRIVE PISTON
RETAINER, OVERRUNNING . . . . . . 21-102,21-269
CLUTCH COIL, COMPRESSOR . . . . . . . . . . . 24-18
CLUTCH, COMPRESSOR
CLUTCH ENGAGEMENT,
ELECTRONICALLY MODULATED
CONVERTER . . . . . . . . . . . . . . . . . . . . . . . 21-336
. . . . . . . 8W-1 CLUTCH, FRONT . . 21-109,21-138,21-197,21-276,
. . . . . . . . 9-49 CLUTCH, LOW/REVERSE
CLUTCH OPERATION, AIR TESTING
. . . 9-155, TRANSMISSION . . . . . . . . . . . . . . . . . . . . . 21-356
9-97 CLUTCH, OVERDRIVE
CLUTCH, OVERRUNNING
CLUTCH, REAR . . . 21-111,21-139,21-198,21-279,
CLUTCH RELAY, COMPRESSOR
. . . . 23-44 CLUTCH SWITCH, ELECTRONIC CYCLING
CLUTCH SWITCH (FRONT UNIT ONLY),
ELECTRONIC CYCLING . . . . . . . . . . . . . . . . 24-19
CLUTCHES, HOLDING
CLUTCHES, INPUT . . . . . . . . . . . . . . . . . . . 21-341
CLUTCH/LOW-REVERSE DRUM/
OVERDRIVE PISTON RETAINER,
OVERRUNNING . . . . . . . . . . . . . . . 21-137,21-305
C—PILLAR SEAL . . . . . . . . . . . . . . . . . . . . . 23-44
COAT FINISH, BASE COAT/CLEAR
COAT HOOK . . . . . . . . . . . . . . . . . . . . . . . . . 23-65
. . . . . 8D-22 COAT/CLEAR COAT FINISH, BASE
CODE DESCRIPTIONS, DIAGNOSTIC
TROUBLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25-3
CODE, PAINT
. . 2-12,2-21,2-26 CODES, DIAGNOSTIC TROUBLE
COIL, COMPRESSOR CLUTCH . . . . . . . . . . . 24-18
COIL, EVAPORATOR
COIL (EXCEPT 4.7L ENGINE), IGNITION . . . . 8D-2
COIL RESISTANCE—4.7L V-8 ENGINE,
. . . . . . 7-22 IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-22
COIL RESISTANCE—EXCEPT 4.7L
ENGINE, IGNITION . . . . . . . . . . . . . . . . . . . 8D-22
21-62 COIL SPRING
COIL SPRINGS
COIL—3.9/5.2/5.9L ENGINES, IGNITION . . . 8D-12
COIL—4.7L ENGINE, IGNITION
COLUMN OPENING COVER, STEERING . . . . 8E-16
COLUMN SHIFT INTERLOCK . . . . . . . . . . . . 8D-21
COLUMN, STEERING . . . . . . . . . . . . . 19-15,19-16
COMBINATION FLASHER
COMBINATION VALVE
. . . . . . . 9-15 COMBUSTION PRESSURE LEAKAGE
TEST, CYLINDER . . . . . . . . . . . . . . . . . 9-12,9-146
COMPASS CALIBRATION . . . . . . . . . . . . . . . . 8V-6
. . . . 8U-5 COMPASS DEMAGNETIZING
COMPASS MINI-TRIP COMPUTER . . . 8V-11,8V-2,
. . . 8E-11, COMPASS VARIATION ADJUSTMENT
8E-4 COMPRESSION PRESSURE TEST,
CYLINDER . . . . . . . . . . . . . . . . . . . . . . 9-11,9-145
COMPRESSOR . . . . . . . . . . . . . . 24-17,24-37,24-4
COMPRESSOR CLUTCH
COMPRESSOR CLUTCH COIL
. . 14-32
COMPRESSOR CLUTCH RELAY . 24-18,24-41,24-5
COMPUTER, COMPASS MINI-TRIP
. . . 8H-2
. 14-37
CONDENSER
. . . . . . 14-6
CONDITIONER CONTROL, HEATER AND
AIR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-8
. . . . . . . . . 0-1
CONDITIONER, HEATER AND AIR
. . . . . . . 14-50
CONDITIONER, REAR OVERHEAD AIR
CONDITIONING/HEATER, 8W-42 AIR
CONDITIONS, SPARK PLUG
CONNECTING ROD ASSEMBLY, PISTON . . . 9-116,
CONNECTING ROD BEARINGS—FITTING . . 9-100,
. . . . . . . . . 8W-1
CONNECTING ROD, PISTON . . . . . 9-140,9-5,9-65,
CONNECTIONS, INTERMITTENT AND
POOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-8
Group-Page
. . . . . . . . . . . 21-381
. . . . . . . . . . . 24-38,24-4
21-307,21-34
. . . . . . . . . . . . . . 21-387
. . . . . . . . . . . 21-199,21-37
. . . . . . . . 21-200,21-37
21-307,21-35
. . . . 24-18,24-41,
24-5
. 24-48,
24-5
. . . . . . . . . . . . . . . . 21-342
. . . . . . . . . 23-2
. . . . . . . . . 23-2
. . . . . . . . . . . . . . . . . . . . . . . . . 23-2
. . . . . . . . . . 25-2
. . . . . . . . . . . . . . 24-48,24-6
. . . . . . . . . . . . . . . . . . . . . . . . . 2-8
. . . . . . . . . . . . . . . . . . . . . . . . 2-7
. . . . . 8D-13,8D-3
. . . . . . . . . . . . 8J-3,8J-5
. . . . . . . . . . . . 5-14,5-3,5-9
. . . . . . . . . . . . . 8V-7
8V-5
. . . . . . 8V-6
. . . . . . . . . . . 24-38,24-4
. . . . . . . . . . . 24-18
. . 8V-11,8V-2,
8V-5
. . . . . . . . . . . . . . . . . . . . 24-41,24-5
. . . . . . . . . 24-7
. . . . . 24-9
. . . . . . 8W-1
. . . . . . . . . . . . . 8D-8
9-124,9-175,9-182
9-157,9-25
9-76,9-90
Description
CONNECTOR AND TERMINAL
REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . 8W-12
CONNECTOR INFORMATION . . . . . . . . . . . . 8W-7
CONNECTOR LOCATIONS, 8W-90
CONNECTOR PIN-OUTS, 8W-80 . . . . . . . . . . 8W-1
CONNECTOR REPLACEMENT . . . . . . . . . . . 8W-12
CONNECTOR/GROUND LOCATIONS
CONNECTOR—PCM INPUT AND
OUTPUT, DATA LINK . . . . . . . . . . . . . . . . . . 14-37
CONNECTORS, TERMINAL/CONNECTOR
REPAIR- AUGAT . . . . . . . . . . . . . . . . . . . . . 8W-11
CONNECTORS, TERMINAL/CONNECTOR
REPAIR-MOLEX . . . . . . . . . . . . . . . . . . . . . 8W-10
CONNECTORS, TERMINAL/CONNECTOR
REPAIR—THOMAS AND BETTS . . . . . . . . . 8W-10
CONSOLE, 8W-49 OVERHEAD . . . . . . . . . . . 8W-1
CONSOLE, FLOOR . . . . . . . . . . . . . . . . . . . . 23-62
CONSOLE, OVERHEAD . . . . . . . . . . . . . 8V-1,8V-9
CONSOLE READING AND COURTESY
LAMP HOUSING, OVERHEAD . . . . . . . . . . . 8V-11
CONSOLE READING AND COURTESY
LAMP LENS, OVERHEAD . . . . . . . . . . . . . . . . 8V-8
CONSOLE READING AND COURTESY
LAMP, OVERHEAD . . . . . . . . . . . . . . . . . . . . . 8V-3
CONSOLE READING LAMP BULB,
OVERHEAD . . . . . . . . . . . . . . . . . . . . . . . . . 8L-14
CONSOLE READING LAMP, OVERHEAD
CONSOLE SYSTEM, OVERHEAD
CONSOLE SYSTEMS, OVERHEAD
CONTACT PATTERN ANALYSIS, GEAR . . . 3-53,3-96
CONTAMINATION, BRAKE FLUID . . . . . . . . . . 5-10
CONTAMINATION, FLUID . . . 21-206,21-352,21-44
CONTROL, 8W-33 VEHICLE SPEED
CONTROL ASSEMBLY, ANTILOCK
CONTROL CABLE, TEMPERATURE
CONTROL, HEATER AND AIR
CONDITIONER . . . . . . . . . . . . . . . . . . . . . . . . 24-8
CONTROL, HEATER-A/C . . . . . . . . . . . 24-20,24-53
CONTROL (IAC) MOTOR—3.9/5.2/5.9L
ENGINES, IDLE AIR . . . . . . . . . . . . . . . . . . . 14-47
CONTROL (IAC) MOTOR—4.7L V–8
ENGINE, IDLE AIR . . . . . . . . . . . . . . . . . . . . 14-48
CONTROL (IAC) MOTOR—PCM OUTPUT,
IDLE AIR . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-37
CONTROL INFORMATION (VECI) LABEL,
VEHICLE EMISSION . . . . . . . . . . . . . . . . . . . 25-29
CONTROL, LINE PRESSURE . . . . . . . . . . . 21-351
CONTROL MODULE, AIRBAG . . . . . . 8M-12,8M-3
CONTROL MODULE (PCM),
POWERTRAIN; FUEL SYSTEM . . . . . . 14-28,14-49
CONTROL MODULE (PCM),
POWERTRAIN; TRANSMISSION AND
TRANSFER CASE . . . . . . . . . . . . . . . 21-202,21-40
CONTROL MODULE, TRANSMISSION
CONTROL RELAY, TRANSMISSION
CONTROL SERVO, SPEED . . . . . . . . . . 8H-2,8H-4
CONTROL SOLENOID CIRCUITS, SPEED
CONTROL SWITCHES, SPEED . . . . . . . 8H-2,8H-5
CONTROL SYSTEM, 8W-31
TRANSMISSION . . . . . . . . . . . . . . . . . . . . . . 8W-1
CONTROL SYSTEM, EVAPORATION . . . . . . . 25-24
CONTROL SYSTEM, SPEED . . . . . . . . . . . . . 8H-1
CONTROL UNIT, HYDRAULIC . . . . . . . . . . . . 5-41
CONTROLLER . . . . . . . . . . . . . . . . . . . . . . . . 5-37
CONTROLLER ANTILOCK BRAKES
CONTROLLER REAR WHEEL ANTILOCK
BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-33
CONTROLS, EVAPORATIVE EMISSION
CONTROLS, OVERDRIVE ELECTRICAL
CONVERTER, CATALYTIC . . . . . . . . . . . . 11-2,11-5
CONVERTER CLUTCH ENGAGEMENT,
ELECTRONICALLY MODULATED . . . . . . . . 21-336
CONVERTER DRAINBACK CHECK VALVE
SERVICE . . . . . . . . . . . . . . . . . . . . . 21-225,21-62
CONVERTER DRAINBACK VALVE . . . 21-202,21-40
CONVERTER HOUSING FLUID LEAK
DIAGNOSIS . . . . . . . . . . . . . 21-211,21-356,21-50
CONVERTER, TORQUE
. . . 21-170,21-229,21-332,
21-364,21-65,21-9
COOLANT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-22
COOLANT FLOW CHECK, RADIATOR . . . . . . . 7-16
COOLANT LEVEL CHECK
. . . . . . . . . . . . . . . . 7-23
COOLANT RESERVE/OVERFLOW SYSTEM
COOLANT RESERVE/OVERFLOW TANK
COOLANT SELECTION AND ADDITIVES
COOLANT SERVICE
. . . . . . . . . . . . . . . . . . . . 7-22
INDEX 3
Group-Page
. . . . . . . . 8W-1
. . . . . . . 8W-1
. . . 8L-20
. . . . . . . . . . 8V-1
. . . . . . . . 8V-14
. . . . . . . 8W-1
. . . . . . . . . 5-44
. . 24-68,24-72
. . . . 21-346
. . . . . . 21-350
. . . 8H-2
. . . . 5-41,5-44
. . . . 25-24
. . . 21-207,
21-45
. . . 7-2
. . . . . 7-25
. . . . 7-23