Page 1 Panel PC 3100 panel mount device User's manual Version: 2.10 (September 2022) Order no.: MAPPC3100-ENG Translation of the original documentation...
Page 2 Publishing information B&R Industrial Automation GmbH B&R Strasse 1 5142 Eggelsberg Austria Telephone: +43 7748 6586-0 Fax: +43 7748 6586-26 office@br-automation.com Disclaimer All information in this document is current as of its creation. The contents of this document are subject to change without notice.
Page 3: Table Of Contents
4.1.4.1 Temperature specifications........................ 38 4.1.4.2 Relative humidity..........................45 4.1.4.3 Vibration and shock........................... 46 4.1.4.4 Degree of protection.......................... 46 4.1.5 Electrical properties..........................47 4.1.5.1 System units - Block diagram......................47 4.1.5.2 Power calculation..........................48 Panel PC 3100 panel mount device User's manual V 2.10...
Page 4 4.2.3.16 5AP1180.1505-000.........................123 4.2.3.17 5AP1181.1043-000.........................126 4.2.3.18 5AP1181.1505-000.........................129 4.2.3.19 5AP1182.1043-000.........................132 4.2.4 Main memory............................134 4.2.4.1 5MMDDR.xxxx-04..........................134 4.2.5 Graphics options............................135 4.2.5.1 5ACCLI02.DPO0-000........................135 4.2.5.2 5ACCLI02.SDL0-000........................137 4.2.5.3 5ACCLI02.SD40-000........................141 4.2.6 Mass storage options..........................143 Panel PC 3100 panel mount device User's manual V 2.10...
Page 5 6.4 Touch screen calibration..........................220 6.4.1 Single-touch (analog resistive)......................220 6.4.1.1 Windows 10 IoT Enterprise......................220 6.4.2 Multi-touch (projected capacitive - PCT)....................220 6.4.2.1 Windows 10 IoT Enterprise......................220 6.5 Display brightness control...........................220 Panel PC 3100 panel mount device User's manual V 2.10...
Page 6 7.3.2.4 Recovery volume options........................ 276 7.3.2.5 Reset disks to non-RAID......................... 277 7.4 Multi-touch drivers............................277 7.5 Operating systems............................278 7.5.1 Windows 10 IoT Enterprise 2019 LTSC....................278 7.5.1.1 General information..........................278 7.5.1.2 Order data............................278 7.5.1.3 Overview............................278 Panel PC 3100 panel mount device User's manual V 2.10...
Page 7 7.9 KCF Editor..............................298 7.10 HMI Service Center..........................299 7.10.1 General information..........................299 7.10.2 Order data............................299 8 Maintenance......................300 8.1 Cleaning..............................300 8.2 Changing the battery..........................301 8.2.1 Changing the battery..........................301 Panel PC 3100 panel mount device User's manual V 2.10...
Page 8 10.2.4 UKCA..............................322 10.2.5 RCM..............................322 10.2.6 DNV certification..........................323 10.2.7 American Bureau of Shipping (ABS)....................323 10.2.8 Bureau Veritas (BV)..........................323 10.2.9 Korean Register of Shipping (KR).......................323 10.2.10 Lloyd's Register (LR)......................... 323 Panel PC 3100 panel mount device User's manual V 2.10...
Page 9 G.1 LED "S/E" (status/error LED)........................345 G.1.1 Ethernet mode............................345 G.1.2 POWERLINK V2 mode.........................345 G.1.3 System stop error codes........................347 G.1.4 POWERLINK V2........................... 347 Appendix H Reading LED status indicators............348 Panel PC 3100 panel mount device User's manual V 2.10...
Page 10: Introduction
"Automation Runtime" on page 289, "B&R Hypervisor" on page 291 "mapp Technology" on page 292. ° Updated section "Installing the interface option and DDR4 SDRAM" on page 304. Editorial corrections are not listed. Panel PC 3100 panel mount device User's manual V 2.10...
Page 11: Information About This Document
Over 6 to 30 mm ±0.2 mm Over 30 to 120 mm ±0.3 mm Over 120 to 400 mm ±0.5 mm Over 400 to 1000 mm ±0.8 mm Table 2: Nominal dimension ranges Panel PC 3100 panel mount device User's manual V 2.10...
Page 12: General Safety Guidelines
2.2.2 Regulations for proper ESD handling Electrical assemblies with housing • Do not touch the connector contacts of connected cables. • Do not touch the contact tips on circuit boards. Panel PC 3100 panel mount device User's manual V 2.10...
Page 13: Regulations And Measures
• General safety regulations and national accident prevention regulations must be observed. • The electrical installation must be carried out in accordance with relevant regulations (e.g. line cross section, fuse protection, protective ground connection). Panel PC 3100 panel mount device User's manual V 2.10...
Page 14: Operation
Internet poses a potential threat to the system. It is the direct responsibility of the user to avert these dangers and to take appropriate measures such as virus protection programs and firewalls to protect against them and to use only software from trustworthy sources. Panel PC 3100 panel mount device User's manual V 2.10...
Page 15: Cybersecurity Disclaimer For Products
The term "control systems" refers to all types of B&R products such as controllers (e.g. X20), HMI systems (e.g. Power Panel T30), process control systems (e.g. APROL) and supporting systems such as engineering workstations with Automation Studio. Panel PC 3100 panel mount device User's manual V 2.10...
Page 16: System Overview
3.2 Scalable Panel PCs Whereas the Automation PC 3100 is designed to control remote panels, the Panel PC 3100 combines a PC and display into a single system. The PC unit can be combined with any panel-mount Automation Panel with a diagonal of 10.1"...
Page 17: Description Of Individual Modules
3.6.2 AP9x3 panels AP9x3 panels form the basis for the Automation Panel 9x3, Panel PC 900, Panel PC 2100, Panel PC 2200 and Panel PC 3100 system families. They consist of a display and touch screen. Different display diagonals and touch screen technologies are available.
Page 18: Ppc3100 Configuration
System overview 3.7 PPC3100 configuration The following individual components are mandatory for operation as a Panel PC 3100: • Panel (observe the minimum revision, see "Requirements for panel functionality" on page • System unit • Main memory • CFast card or M.2 mass storage device for the operating system •...
Page 19 Select a graphics option or mass storage option. The UPS module can only be operated in the IF option 1 slot, and the battery unit compatible with the UPS module must be used. Panel PC 3100 panel mount device User's manual V 2.10...
Page 20: Requirements For Panel Functionality
System overview 3.7.1 Requirements for panel functionality In order to ensure the functionality of panels with the Panel PC 3100, the following revision or later must be used: AP1000 panels: AP9x3 panels: 5AP1120.1043-000, Rev. E0 or later 5AP923.1215-00, Rev. E0 or later 5AP1120.101E-000, Rev.
Page 21: Overview
5AP1120.156B-000 Automation Panel 15.6" HD TFT - 1366 x 768 pixels (16:9) - Single-touch (analog resistive) - Control cabinet installation - Landscape format - For PPC900/PPC2100/PPC3100/PPC2200 - For link modules Panel PC 3100 panel mount device User's manual V 2.10...
Page 22 UPS cable - 0.5 m - For 5AC901.IUPS-xx 5CAUPS.0010-01 UPS cable - 1 m - For 5AC901.IUPS-xx 5CAUPS.0013-01 UPS cable - 1.3 m - For 5AC901.IUPS-xx 5CAUPS.0030-01 UPS cable - 3 m - For 5AC901.IUPS-xx Panel PC 3100 panel mount device User's manual V 2.10...
Page 23 Windows 10 IoT Enterprise 2019 LTSC: - 64-bit - Value - Multilingual - License - Only available with a new device 5SWW10.1100-MUL Windows 10 IoT Enterprise 2019 LTSC: - 64-bit - High End - Multilingual - License - Only available with a new device Panel PC 3100 panel mount device User's manual V 2.10...
Page 24: Technical Data
4.1 Complete system 4.1.1 Connection options Additional Automation Panels can be connected directly to the Panel PC 3100 via the onboard DVI-D/SDL interface and an optional graphics option. The connection options described in the following provide an overview of the operating modes and possible limitations.
Page 25 COM interface for touch Grounding screen Maximum cable length: 5 m Requirements • Automation Panel with SDL/DVI receiver • B&R industrial PC with SDL interface • SDL cable, USB type A/B cable Panel PC 3100 panel mount device User's manual V 2.10...
Page 26: Dvi Operation
• DVI cable, USB type A/B cable 4.1.1.2.3 General limitations • Key and LED data is not transferred. • Service and diagnostic data is not transferred. • Updating the firmware of Automation Panels is not possible. Panel PC 3100 panel mount device User's manual V 2.10...
Page 27: Sdl4 Operation
° There is no connection established yet between the SDL4 link module and SDL4 transmitter. This behavior can be avoided by appropriate configuration in BIOS or via the graphics driver. Panel PC 3100 panel mount device User's manual V 2.10...
Page 28: Product Information
The device number can be retrieved from the B&R website (www.br-automation.com) using the serial number of the device (login required). Information (serial number, material number, revision, delivery date and end of warranty) about all components installed in the system can be retrieved using the device number. Panel PC 3100 panel mount device User's manual V 2.10...
Page 29: Mechanical Properties
72.5 245.5 Rev. D0 and later 18.5" multi-touch 5AP933.185B-00 133.5 21.5" multi-touch 5AP933.215C-00 541.5 528.5 166.75 24.0" multi-touch 5AP933.240C-00 598.5 585.5 195.25 Components Type Order number System units 5PPC3100.KBUx-000 173.5 Panel PC 3100 panel mount device User's manual V 2.10...
Page 30 Rev. A0 15.6" multi-touch 5AP1130.156C-000 258.5 72.5 245.5 Rev. A2 and later 15.6" multi-touch 5AP1130.156C-001 258.5 72.5 245.5 18.5" multi-touch 5AP1130.185C-000 133.5 Components Type Order number System units 5PPC3100.KBUx-000 173.5 Panel PC 3100 panel mount device User's manual V 2.10...
Page 31 24.3 10.5 15.0" single-touch with keys 5AP1180.1505-000 48.5 24.3 10.5 15.0" single-touch with keys 5AP1181.1505-000 48.5 24.3 19.0" single-touch 5AP1120.1906-000 153.5 23.3 Components Type Order number System units 5PPC3100.KBUx-000 173.5 Panel PC 3100 panel mount device User's manual V 2.10...
Page 32: Installation Diagrams
Technical data 4.1.3.2 Installation diagrams Information: When installing the Panel PC 3100, spacing for air circulation and additional free space for operating and servicing the device must be taken into account. The cutout tolerances are +0 mm / -0.5 mm.
Page 33 A 2.5 mm hex screwdriver is needed to tighten and remove the screw on the retaining clips. The maximum tightening torque of the retaining clips is 1 Nm. Information: A minimum circumferential distance of 30 mm must be maintained in order to enable installation with retaining clips. Panel PC 3100 panel mount device User's manual V 2.10...
Page 34 Dimension "Z" describes the thickness of the wall or control cabinet plate. A 3 mm hex screwdriver is needed to tighten or remove the screw on the clamping blocks. The maximum tightening torque of the clamping block is 0.5 Nm. Panel PC 3100 panel mount device User's manual V 2.10...
Page 35: Spacing For Air Circulation
If the specified spacing for air circulation cannot be maintained, the maximum specified temperatures of the temperature sensors (see "Temperature sensor positions" on page 44) must be monitored in the application and appropriate measures taken if these values are exceeded. Panel PC 3100 panel mount device User's manual V 2.10...
Page 36: Mounting Orientations
Technical data 4.1.3.4 Mounting orientations The following diagrams show the specified mounting orientations of Panel PC 3100 devices. These are only per- mitted to be installed as specified below. Inclination [°] Derating [°C] Inclination [°] Derating No limitation No limitation Up to ±90...
Page 37: Weight Specifications
Graphics options 5ACCLI02.SDL0-000 5ACCLI02.SD40-000 5AC901.I232-00 5AC901.I485-00 5AC901.ICAN-00 5AC901.ICAN-01 5AC901.IHDA-00 5AC901.IRDY-00 5AC901.IPLK-00 5AC901.ISIO-00 Interface options 5AC901.ISRM-00 5AC901.IETH-00 5ACCIF02.CANE-000 5ACCIF02.FPLK-000 5ACCIF02.FPLS-000 5ACCIF02.FPSC-000 5ACCIF02.ISS0-000 5ACCIF04.FPLK-000 Mass storage options 5ACCMS01.MDT2-000 Without mass storage device. Panel PC 3100 panel mount device User's manual V 2.10...
Page 38: Environmental Properties
• BurnInTest V7.1 Pro from PassMark Software for simulating 100% interface utilization using loopback adapters (100% network) • 4x 1 A USB load • Maximum expansion and power consumption of the system • 100 % display brightness Panel PC 3100 panel mount device User's manual V 2.10...
Page 39 It may be necessary to limit the max. ambient temperature in certain applications (e.g. UL HazLoc) (for additional information, see "International and national certifications" on page 320). 4.1.4.1.2 Minimum ambient temperature for worst-case operation The minimum ambient temperature for non-condensing operation is 0°C. Panel PC 3100 panel mount device User's manual V 2.10...
Page 40 5ACCIF04.FPLK-000 Mass storage options 5ACCMS01.MDT2-000 ✓ ✓ ✓ ✓ Max. 15 W without USB Max. 17 W without USB These values can be limited by the mass storage device used. Panel PC 3100 panel mount device User's manual V 2.10...
Page 41 5. The relevant test and assessment must be carried out individually by the user on site (reading out the tem- peratures in BIOS or using the ADI Control Center). See section "Information about typical conditions" on page Panel PC 3100 panel mount device User's manual V 2.10...
Page 42 -20 to 60 5ACCIF04.FPLK-000 -20 to 60 -20 to 60 Mass storage option 5ACCMS01.MDT2-000 -20 to 60 -20 to 60 These values can be limited by the mass storage device used. Panel PC 3100 panel mount device User's manual V 2.10...
Page 43 Microsoft Windows or Linux for B&R operating systems. The measured temperature is a guide value for the immediate ambient temperature, but it may have been influenced by neighboring components. Self-Monitoring, Analysis and Reporting Technology Panel PC 3100 panel mount device User's manual V 2.10...
Page 44 System unit sensor 4 Temperature of the processor 95°C IF option 3 slot Graphics option Temperature of a graphics option (sensor integrated on the graphics option) Depends on the graphics option Panel PC 3100 panel mount device User's manual V 2.10...
Page 45: Relative Humidity
5 to 95 5 to 95 Mass storage options 5ACCMS01.MDT2-000 5 to 90 5 to 95 5 to 95 These values can be limited by the mass storage device used. Panel PC 3100 panel mount device User's manual V 2.10...
Page 46: Vibration And Shock
• Installation of all covers or components on interfaces and slots • Compliance with all ambient conditions The Panel PC 3100 with AP9x3 and AP1000 panels additionally has "Type 4X indoor use only" on the front per UL 50 under the same conditions.
Page 47: Electrical Properties
IF option 2 Magnetics Display Magnetics connector IF option 3 (graphics option) Legend 2.0_Px USB 2.0 port x Internal interface External interface 3.0_Px USB 3.0 port x Internal interface, removable/configurable Panel PC 3100 panel mount device User's manual V 2.10...
Page 48: Power Calculation
Technical data 4.1.5.2 Power calculation In order to calculate the total power of the Panel PC 3100, the power ratings of the system unit used, the panel and all other installed components must be added together. Information: Unless otherwise specified, the following values are maximum values and additional consumers (e.g.
Page 49 2x CFast card 5CFAST.xxxx-10 2x 2.03 W 4.06 W Total max.: 68.26 W Table 4: Power calculation with example configuration 2 For detailed revision-dependent information, see aggregate data sheet for CFast cards. Panel PC 3100 panel mount device User's manual V 2.10...
Page 50: Device Interfaces And Slots
"IF option 2 slot" on page 59 "Power and reset buttons" on page 54 "SDL/DVI-D interface" on page 57 IF option 3 slot "Battery" on page 56 "CFast slots" on page 54 Panel (configuration-dependent) Panel PC 3100 panel mount device User's manual V 2.10...
Page 51: Vdc Power Supply
For example, a copper strip must be attached to the ground connection at a central grounding point of the control cabinet or system in which the device is installed. The wire cross section should be as large as possible (at least 2.5 mm²). Panel PC 3100 panel mount device User's manual V 2.10...
Page 52: Ethernet Interfaces
A special driver is required to operate the Ethernet controller. Drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com). Information: Necessary drivers must be downloaded from the B&R website, not from manufacturer websites. Panel PC 3100 panel mount device User's manual V 2.10...
Page 53: Usb Interfaces
High speed (480 Mbit/s) Current-carrying capacity USB5 Max. 0.5 A Cable length Internal for Technology Guard The USB interface is protected by a maintenance-free "USB current-limiting switch" (max. 0.5 A). Panel PC 3100 panel mount device User's manual V 2.10...
Page 54: Cfast Slots
Pressing the reset button triggers a hardware/PCI reset. The PC is restarted. During a reset, the MTCX processor is not reset. Warning! Switching off the power without shutting down or resetting the system can result in data loss! Panel PC 3100 panel mount device User's manual V 2.10...
Page 55: Led Status Indicators
Application in SERVICE mode Controlled by Automation Runtime (ARemb and AR- win). Orange Blinking A license violation has occurred. Two columns form 1 interval of 500 ms each. S5: Soft-off S4: Hibernate (suspend-to-disk) Panel PC 3100 panel mount device User's manual V 2.10...
Page 56: Battery
As soon as the battery capacity is recognized as BAD (insufficient), retention of data is ensured for approximately another 500 hours. The battery must be replaced. When changing the battery, data is retained for approximately 10 minutes by a gold foil capacitor. Panel PC 3100 panel mount device User's manual V 2.10...
Page 57: Sdl/Dvi-D Interface
5CASDL.0200-00 5CASDL.0200-00 5CASDL.0200-03 5CASDL.0200-03 5CASDL.0200-03 5CASDL.0200-03 5CASDL.0200-03 5CASDL.0200-03 5CASDL.0250-00 5CASDL.0250-00 5CASDL.0250-00 5CASDL.0250-00 5CASDL.0250-03 5CASDL.0250-03 5CASDL.0250-03 5CASDL.0250-03 5CASDL.0300-00 5CASDL.0300-00 5CASDL.0300-03 5CASDL.0300-03 5CASDL.0300-13 5CASDL.0300-13 5CASDL.0300-13 5CASDL.0300-13 5CASDL.0400-13 5CASDL.0400-13 5CASDL.0400-13 5CASDL.0400-13 5CASDL.0400-13 5CASDL.0400-13 Panel PC 3100 panel mount device User's manual V 2.10...
Page 58: If Option 1 Slot
The maximum cable length for DVI transfer is limited to 5 m due to the USB specification. 4.1.6.11 IF option 1 slot Panel PC 3100 system units have 3 slots for interface options. The following table lists the interface options that can be used in the IF option 1 slot.
Page 59: If Option 2 Slot
Technical data 4.1.6.12 IF option 2 slot Panel PC 3100 system units have 3 slots for interface options. The following table lists the interface options that can be used in the IF option 2 slot. IF option 2 slot Order number Interface option - Short description 5AC901.I232-00...
Page 60: If Option 3 Slot
Technical data 4.1.6.13 IF option 3 slot Panel PC 3100 system units have 3 slots for interface options. The following table lists the interface options that can be used in the IF option 3 slot. IF option 3 slot Order number Graphics option - Short description 5ACCLI02.DPO0-000...
Page 61: Trusted Platform Module (Tpm)
If the password for data encryption is lost, it is not possible to decrypt the data, e.g. after a BIOS update or TPM firmware update. Access to the encrypted drive is lost. Passwords must be carefully stored and protected from unauthorized access. Panel PC 3100 panel mount device User's manual V 2.10...
Page 62: Features Of Ap1000 Panels
It is also possible to download a template for slide-in labels with individual captions from the B&R website (www.br-automation.com). The slots provided for slide-in labels are accessible on the rear of the Automation Panel devices. Panel PC 3100 panel mount device User's manual V 2.10...
Page 63: Key And Led Configuration
• Hardware numbers of keys are specified in the follow- Operating element with LED ing with black indexes. • Hardware numbers of LEDs are specified in the follow- ing with blue indexes. Key with LED 5AP1180.1043-000 Panel PC 3100 panel mount device User's manual V 2.10...
Page 64 Technical data 5AP1181.1043-000 5AP1182.1043-000 5AP1180.1505-000 Panel PC 3100 panel mount device User's manual V 2.10...
Page 65 Technical data 5AP1181.1505-000 Panel PC 3100 panel mount device User's manual V 2.10...
Page 66: Usb Interface
The interfaces, etc. available on the device or module have been numbered for the purpose of clear differentiation. This numbering may deviate from the numbering used by the respective operating system, however. The USB interface is protected by a maintenance-free "USB current-limiting switch" (max. 0.5 A). Panel PC 3100 panel mount device User's manual V 2.10...
Page 67: Individual Components
The main memory can be replaced or expanded. • Intel Core i-series processors • DDR4 memory • Intel HD Graphics • 2 CFast slots • Slots for 3 interface options • Replaceable and expandable main memory Panel PC 3100 panel mount device User's manual V 2.10...
Page 68 Mass storage options 5ACCMS01.MDT2-000 Adapter card for M.2 mass storage device - For APC3100/ PPC3100 Uninterruptible power supply 5AC901.IUPS-00 UPS - For 4.5 Ah battery 5AC901.IUPS-01 UPS - For 2.2 Ah battery Panel PC 3100 panel mount device User's manual V 2.10...
Page 69 Power failure logic Controller MTCX Buffer time 10 ms Memory Removable Memory slot Number of memory channels Type DDR4 SDRAM Memory size Max. 32 GB Max. memory bandwidth 34.1 GB/s Panel PC 3100 panel mount device User's manual V 2.10...
Page 70 Only if all interface covers are installed. The maximum ambient temperature is typically derated 1°C per 1000 meters starting at 500 m above sea level. All dimensions without mounting plate. Panel PC 3100 panel mount device User's manual V 2.10...
Page 71: Ap9X3 Panels
Degree of protection per EN 60529 Front: IP65 Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Panel PC 3100 panel mount device User's manual V 2.10...
Page 72 4.2.2.1.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 73: 5Ap923.1505-00
Direction R = 80° / Direction L = 80° Vertical Direction U = 70° / Direction D = 70° Backlight Type Brightness (dimmable) Typ. 20 to 400 cd/m² Half-brightness time 50,000 h Panel PC 3100 panel mount device User's manual V 2.10...
Page 74 4.2.2.2.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 75: 5Ap923.1906-00
Degree of protection per EN 60529 Front: IP65 Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Panel PC 3100 panel mount device User's manual V 2.10...
Page 76 5AP923.1906-00 ≥ Rev. E0 RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 77 5AP923.1906-00 ≤ Rev. D0 RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C RH [%] Relative humidity (RH) in percent and non-condensing Storage and transport Panel PC 3100 panel mount device User's manual V 2.10...
Page 78: 5Ap933.156B-00
Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Mechanical properties Front Frame Aluminum, coated Design Black Gasket 3 mm fixed gasket Panel PC 3100 panel mount device User's manual V 2.10...
Page 79 5AP933.156B-00 ≥ Rev. D0 RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 80 5AP933.156B-00 ≤ Rev. C0 RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C RH [%] Relative humidity (RH) in percent and non-condensing Storage and transport Panel PC 3100 panel mount device User's manual V 2.10...
Page 81: 5Ap933.185B-00
Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Mechanical properties Front Frame Aluminum, coated Design Black Gasket 3 mm fixed gasket Panel PC 3100 panel mount device User's manual V 2.10...
Page 82 5AP933.185B-00 ≥ Rev. D0 RH [%] T [°C] -20 - 0 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 83 5AP933.185B-00 ≤ Rev. C0 RH [%] T [°C] -20 - 0 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 84: 5Ap933.215C-00
Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Mechanical properties Front Frame Aluminum, coated Design Black Gasket 3 mm fixed gasket Panel PC 3100 panel mount device User's manual V 2.10...
Page 85 5AP933.215C-00 ≥ Rev. D0 RH [%] T [°C] -20 - 0 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 86 5AP933.215C-00 ≤ Rev. C0 RH [%] T [°C] -20 - 0 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 87: 5Ap933.240C-00
Degree of protection per EN 60529 Front: IP65 Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Panel PC 3100 panel mount device User's manual V 2.10...
Page 88 5AP933.240C-00 ≥ Rev. D0 RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 89 5AP933.240C-00 ≤ Rev. C0 RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C RH [%] Relative humidity (RH) in percent and non-condensing Storage and transport Panel PC 3100 panel mount device User's manual V 2.10...
Page 90: Ap1000 Panels
Direction U = 80° / Direction D = 80° Backlight Type Brightness (dimmable) Typ. 22.5 to 450 cd/m² Half-brightness time 70,000 h Touch screen Technology Analog, resistive Controller B&R, serial, 12-bit Transmittance 81% ±3% Panel PC 3100 panel mount device User's manual V 2.10...
Page 91 4.2.3.1.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C RH [%] Relative humidity (RH) in percent and non-condensing Storage and transport Panel PC 3100 panel mount device User's manual V 2.10...
Page 92: 5Ap1120.101E-000
Degree of protection per EN 60529 Front: IP65 Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Panel PC 3100 panel mount device User's manual V 2.10...
Page 93 4.2.3.2.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 94: 5Ap1120.1214-000
81% ±3% Interfaces Quantity Type USB 2.0 Variant Type A Transfer rate Low speed (1.5 Mbit/s), full speed (12 Mbit/s) to high speed (480 Mbit/s) Current-carrying capacity Max. 500 mA Panel PC 3100 panel mount device User's manual V 2.10...
Page 95 4.2.3.3.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 96: 5Ap1120.121E-000
Degree of protection per EN 60529 Front: IP65 Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Panel PC 3100 panel mount device User's manual V 2.10...
Page 97 4.2.3.4.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 98: 5Ap1120.1505-000
81% ±3% Interfaces Quantity Type USB 2.0 Variant Type A Transfer rate Low speed (1.5 Mbit/s), full speed (12 Mbit/s) to high speed (480 Mbit/s) Current-carrying capacity Max. 500 mA Panel PC 3100 panel mount device User's manual V 2.10...
Page 99 4.2.3.5.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 100: 5Ap1120.156B-000
Degree of protection per EN 60529 Front: IP65 Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Panel PC 3100 panel mount device User's manual V 2.10...
Page 101 Hardware revision H0 and later RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 102 Up to hardware revision G0 RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C RH [%] Relative humidity (RH) in percent and non-condensing Storage and transport Panel PC 3100 panel mount device User's manual V 2.10...
Page 103: 5Ap1120.1906-000
Direction R = 85° / Direction L = 85° Vertical Direction U = 85° / Direction D = 85° Backlight Type Brightness (dimmable) Typ. 35 to 350 cd/m² Half-brightness time 70,000 h Panel PC 3100 panel mount device User's manual V 2.10...
Page 104 Touch screen drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com). Visual deviations in color and surface quality are possible due to process or batch conditions. 4.2.3.7.4 Dimensions Panel PC 3100 panel mount device User's manual V 2.10...
Page 105 4.2.3.7.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 106: 5Ap1130.101D-000
Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Mechanical properties Front Frame Aluminum, coated Design Black Gasket 3 mm fixed gasket Panel PC 3100 panel mount device User's manual V 2.10...
Page 107 4.2.3.8.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 108: 5Ap1130.101E-000
Starting with hardware revision I0: Typ 25 to 1000 cd/m² Up to hardware revision H0: Typ. 25 to 500 cd/m² Half-brightness time 50,000 h Touch screen Technology Projected capacitive touch (PCT) Transmittance See "Appendix A - Touch screen". Panel PC 3100 panel mount device User's manual V 2.10...
Page 109 4.2.3.9.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 110: 5Ap1130.121E-000
Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Mechanical properties Front Frame Aluminum, coated Design Black Gasket 3 mm fixed gasket Panel PC 3100 panel mount device User's manual V 2.10...
Page 111 4.2.3.10.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 112: 5Ap1130.121E-010
Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Mechanical properties Front Frame Aluminum, coated Design Black Gasket 3 mm fixed gasket Panel PC 3100 panel mount device User's manual V 2.10...
Page 113 4.2.3.11.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C RH [%] Relative humidity (RH) in percent and non-condensing Storage and transport Panel PC 3100 panel mount device User's manual V 2.10...
Page 114: 5Ap1130.156C-000
Typ. 40 to 450 cd/m² Half-brightness time ≥50,000 h Touch screen Technology Projected capacitive touch (PCT) Transmittance See "Appendix A - Touch screen". Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Panel PC 3100 panel mount device User's manual V 2.10...
Page 115 4.2.3.12.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 116: 5Ap1130.156C-001
Back: IP20 (only with installed link module or installed system unit) Degree of protection per UL 50 Front: Type 4X indoor use only Mechanical properties Front Frame Aluminum, coated Design Black Gasket 3 mm fixed gasket Panel PC 3100 panel mount device User's manual V 2.10...
Page 117 4.2.3.13.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C RH [%] Relative humidity (RH) in percent and non-condensing Storage and transport Panel PC 3100 panel mount device User's manual V 2.10...
Page 118: 5Ap1130.185C-000
Typ. 40 to 400 cd/m² Half-brightness time 50,000 h Touch screen Technology Projected capacitive touch (PCT) Transmittance See "Appendix A - Touch screen". Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Panel PC 3100 panel mount device User's manual V 2.10...
Page 119 4.2.3.14.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 120: 5Ap1180.1043-000
Direction U = 80° / Direction D = 80° Backlight Type Brightness (dimmable) Typ. 22.5 to 450 cd/m² Half-brightness time 70,000 h Touch screen Technology Analog, resistive Controller B&R, serial, 12-bit Transmittance 81% ±3% Panel PC 3100 panel mount device User's manual V 2.10...
Page 121 Touch screen drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com). Visual deviations in color and surface quality are possible due to process or batch conditions. 4.2.3.15.4 Dimensions Panel PC 3100 panel mount device User's manual V 2.10...
Page 122 4.2.3.15.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 123: 5Ap1180.1505-000
Direction U = 70° / Direction D = 70° Backlight Type Brightness (dimmable) Typ. 20 to 400 cd/m² Half-brightness time 50,000 h Touch screen Technology Analog, resistive Controller B&R, serial, 12-bit Transmittance 81% ±3% Panel PC 3100 panel mount device User's manual V 2.10...
Page 124 Touch screen drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com). Visual deviations in color and surface quality are possible due to process or batch conditions. 4.2.3.16.4 Dimensions Panel PC 3100 panel mount device User's manual V 2.10...
Page 125 4.2.3.16.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 126: 5Ap1181.1043-000
Direction U = 80° / Direction D = 80° Backlight Type Brightness (dimmable) Typ. 22.5 to 450 cd/m² Half-brightness time 70,000 h Touch screen Technology Analog, resistive Controller B&R, serial, 12-bit Transmittance 81% ±3% Panel PC 3100 panel mount device User's manual V 2.10...
Page 127 Touch screen drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com). Visual deviations in color and surface quality are possible due to process or batch conditions. 4.2.3.17.4 Dimensions Panel PC 3100 panel mount device User's manual V 2.10...
Page 128 4.2.3.17.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 129: 5Ap1181.1505-000
Direction R = 80° / Direction L = 80° Vertical Direction U = 70° / Direction D = 70° Backlight Type Brightness (dimmable) Typ. 20 to 400 cd/m² Half-brightness time 50,000 h Panel PC 3100 panel mount device User's manual V 2.10...
Page 130 Touch screen drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com). Visual deviations in color and surface quality are possible due to process or batch conditions. 4.2.3.18.4 Dimensions Panel PC 3100 panel mount device User's manual V 2.10...
Page 131 4.2.3.18.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 132: 5Ap1182.1043-000
81% ±3% Interfaces Quantity Type USB 2.0 Variant Type A Transfer rate Low speed (1.5 Mbit/s), full speed (12 Mbit/s) to high speed (480 Mbit/s) Current-carrying capacity Max. 500 mA Panel PC 3100 panel mount device User's manual V 2.10...
Page 133 4.2.3.19.5 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 134: Main Memory
Pollution degree 2 Yes, but applies only if all components installed in the complete system have this certification and are listed on the associated DNV certificate for the product family. Panel PC 3100 panel mount device User's manual V 2.10...
Page 135: Graphics Options
Variant Type A Transfer rate Low speed (1.5 Mbit/s), full speed (12 Mbit/s) to high speed (480 Mbit/s) Current-carrying capacity Max. 0.5 A DisplayPort Quantity Version Electrical properties Power consumption Panel PC 3100 panel mount device User's manual V 2.10...
Page 136 Hot plugging output devices on the interface for service purposes is supported by the hardware and graphic drivers of approved operating systems. A maximum of 10,000 mating cycles are specified for this interface. Panel PC 3100 panel mount device User's manual V 2.10...
Page 137: 5Accli02.Sdl0-000
SDL/DVI Electrical properties Power consumption Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 60°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 138 Yes, but applies only if all components installed in the complete system have this certification and are listed on the associated DNV certificate for the product family. For detailed information, see the temperature tables in the user's manual. Panel PC 3100 panel mount device User's manual V 2.10...
Page 139 In SDL operation without USB type A/B cable, the USB transfer rate is limited to USB 1.1. A USB transfer rate of USB 2.0 is possible in DVI or SDL operation with a USB type A/B cable. Panel PC 3100 panel mount device User's manual V 2.10...
Page 140 5CADVI.0018-00 5CADVI.0018-00 5CADVI.0018-00 5CADVI.0018-00 5CADVI.0018-00 5CADVI.0018-00 5CADVI.0018-00 5CADVI.0050-00 5CADVI.0050-00 5CADVI.0050-00 5CADVI.0050-00 5CADVI.0050-00 5CADVI.0050-00 5CADVI.0050-00 The maximum cable length for DVI transfer is limited to 5 m due to the USB specification. Panel PC 3100 panel mount device User's manual V 2.10...
Page 141: 5Accli02.Sd40-000
5 to 90%, non-condensing Storage 5 to 95%, non-condensing Transport 5 to 95%, non-condensing Mechanical properties Weight Approx. 38 g For detailed information, see the temperature tables in the user's manual. Panel PC 3100 panel mount device User's manual V 2.10...
Page 142 4.2.5.3.3.2 Cable lengths and resolutions for SDL4 transfer The maximum cable length for SDL4 transfer with a B&R SDL3/SDL4 cable is 100 meters (regardless of the resolution of the panel). Panel PC 3100 panel mount device User's manual V 2.10...
Page 143: Mass Storage Options
Adapter card for M.2 mass storage device - For APC3100/ PPC3100 Optional accessories Mass storage options 5ACCMSM2.0512-000 512 GB M.2 SSD MLC - Innodisk - SATA 5ACCMSM2.1024-000 1 TB M.2 SSD MLC - Innodisk - SATA Panel PC 3100 panel mount device User's manual V 2.10...
Page 144 Adapter card 5ACCMS01.MDT2-000 has a yellow LED status indicator on the front panel that serves as an activity indicator. • On: Mass storage device being accessed (write or read procedure) • Off: Mass storage device not being accessed Panel PC 3100 panel mount device User's manual V 2.10...
Page 145: 5Accmsm2.Xxxx-000
SATA 3.1 compliant ACS-2 SSD Enhanced SMART ATA feature set Native Command Queuing (NCQ) Storage health data support Yes, AR 4.90 and later Electrical properties Power consumption Max. 3.5 W Panel PC 3100 panel mount device User's manual V 2.10...
Page 146 4.2.6.2.4 Installing M.2 mass storage devices The installation of M.2 mass storage devices in adapter card 5ACCMS01.MDT2-000 is described in section "In- stalling M.2 mass storage devices" on page 308. Panel PC 3100 panel mount device User's manual V 2.10...
Page 147: Interface Options
115 kbit/s Electrical properties Power consumption Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 60°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 148 Drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com) (if required and not already included in the operating system). Approved operating systems: • Automation Runtime • Linux for B&R • Windows 10 Panel PC 3100 panel mount device User's manual V 2.10...
Page 149: 5Ac901.I485-00
115 kbit/s Terminating resistor Type Can be switched on and off with slide switch Default setting Electrical properties Power consumption Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Panel PC 3100 panel mount device User's manual V 2.10...
Page 150 The default I/O address and IRQ can be modified in BIOS. 4.2.7.2.3.3 Cable data For more detailed information about the transfer rate, bus length or cable requirements for the respective inter- faces/buses, see "Cable data" on page 343. Panel PC 3100 panel mount device User's manual V 2.10...
Page 151 Drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com) (if required and not already included in the operating system). Approved operating systems: • Automation Runtime • Linux for B&R • Windows 10 Panel PC 3100 panel mount device User's manual V 2.10...
Page 152: 5Ac901.Ican-00
Default setting Electrical properties Power consumption Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 60°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 153 89h or 09h 50 kbit/s 4.2.7.3.3.4 Cable data For more detailed information about the transfer rate, bus length or cable requirements for the respective inter- faces/buses, see "Cable data" on page 343. Panel PC 3100 panel mount device User's manual V 2.10...
Page 154 Drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com) (if required and not already included in the operating system). Approved operating systems: • Automation Runtime • Windows 10 • Linux for B&R Panel PC 3100 panel mount device User's manual V 2.10...
Page 155: 5Ac901.Ican-01
Yes, but applies only if all components installed in the complete system have this certification and the complete system bears the corresponding mark. For detailed information, see the temperature tables in the user's manual. Panel PC 3100 panel mount device User's manual V 2.10...
Page 156 Drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com) (if required and not already included in the operating system). Approved operating systems: • Linux for B&R • Windows 10 Panel PC 3100 panel mount device User's manual V 2.10...
Page 157: 5Ac901.Ihda-00
Type HDA sound Controller Realtek ALC 662 Inputs Microphone, Line In Outputs Line Out Electrical properties Power consumption 0.4 W Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Panel PC 3100 panel mount device User's manual V 2.10...
Page 158 Downloads section of the B&R website (www.br-automation.com) (if required and not already included in the operating system). Information: Necessary drivers must be downloaded from the B&R website, not from manufacturer websites. Panel PC 3100 panel mount device User's manual V 2.10...
Page 159: 5Ac901.Isrm-00
Yes, but applies only if all components installed in the complete system have this certification and the complete system bears the corresponding mark. For detailed information, see the temperature tables in the user's manual. Panel PC 3100 panel mount device User's manual V 2.10...
Page 160 Drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com) (if required and not already included in the operating system). Approved operating systems: • Windows 10 • Automation Runtime Panel PC 3100 panel mount device User's manual V 2.10...
Page 161: 5Ac901.Iplk-00
POWERLINK Quantity Type Type 4 Variant RJ45, shielded Transfer rate 100 Mbit/s Transfer 100BASE-TX Line length Max. 100 m between two stations (segment length) Electrical properties Power consumption 1.5 W Panel PC 3100 panel mount device User's manual V 2.10...
Page 162 To update the firmware contained in Automation Studio, a hardware upgrade must be performed (see Project management / Workspace / Upgrades in Automation Help). Panel PC 3100 panel mount device User's manual V 2.10...
Page 163: 5Ac901.Irdy-00
For detailed information, see the temperature tables in the user's manual. 4.2.7.8.3.1 Pinout Ready relay Pinout Description Connector, 4-pin, male Normally open contact Changeover contact Normally closed contact Not connected Panel PC 3100 panel mount device User's manual V 2.10...
Page 164: 5Ac901.Isio-00
Electrical properties Power consumption 0.5 W Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 60°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 165 "Power and reset buttons" on page 4.2.7.9.3.2 Connection example Information: Series resistors for the LEDs are already installed on the interface option. The LED outputs are dimensioned for a typical LED current of 3.5 mA. Panel PC 3100 panel mount device User's manual V 2.10...
Page 166: 5Ac901.Ieth-00
Max. 100 m between two stations (segment length) Electrical properties Power consumption Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 55°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 167 Yes, but applies only if all components installed in the complete system have this certification and are listed on the associated DNV certificate for the product family. Switching takes place automatically. For detailed information, see the temperature tables in the user's manual. Panel PC 3100 panel mount device User's manual V 2.10...
Page 168 Approved operating systems: • Linux for B&R • Windows 10 Information: Necessary drivers must be downloaded from the B&R website, not from manufacturer websites. Wake-on-LAN (WoL) and PXE boot are not supported. Panel PC 3100 panel mount device User's manual V 2.10...
Page 169: 5Accif02.Cane-000
Terminating resistor Type Can be switched on and off with slide switch Default setting Electrical properties Power consumption 1.5 W Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Panel PC 3100 panel mount device User's manual V 2.10...
Page 170 Switching takes place automatically. The 10 Mbit/s transfer rate / connection is only available if LED "Link" is active at the same time. Panel PC 3100 panel mount device User's manual V 2.10...
Page 171 (1); it is necessary to open the system unit for this. A switched-on terminating resistor is indicated by a yellow LED (2) (see "Reading LED status indicators" on page 348). Panel PC 3100 panel mount device User's manual V 2.10...
Page 172 Approved operating systems: • Linux for B&R • Windows 10 Information: Necessary drivers must be downloaded from the B&R website, not from manufacturer websites. Wake-on-LAN (WoL) and PXE boot are not supported. Panel PC 3100 panel mount device User's manual V 2.10...
Page 173: 5Accif02.Fplk-000
UKCA cULus E115267 Industrial control equipment Product family certification Controller SRAM Size 2 MB Battery-backed Remanent variables in power failure mode 256 kB (for e.g. Automation Runtime, see Automation Help) Panel PC 3100 panel mount device User's manual V 2.10...
Page 174 4.2.7.12.3.3 POWERLINK commissioning and operation For a description of the operating modes, status and node numbers of the POWERLINK interface(s), see "LED "S/E" (status/error LED)" on page 345. Panel PC 3100 panel mount device User's manual V 2.10...
Page 175 To update the firmware contained in Automation Studio, a hardware upgrade must be performed (see Project management / Workspace / Upgrades in Automation Help). Panel PC 3100 panel mount device User's manual V 2.10...
Page 176: 5Accif02.Fpls-000
100 Mbit/s Transfer 100BASE-TX Line length Max. 100 m between two stations (segment length) Electrical properties Power consumption 1.75 W Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Panel PC 3100 panel mount device User's manual V 2.10...
Page 177 The respective default values for the I/O address and IRQ can be modified in BIOS. Cable data For more detailed information about the transfer rate, bus length or cable requirements for the respective inter- faces/buses, see "Cable data" on page 343. Panel PC 3100 panel mount device User's manual V 2.10...
Page 178 General purpose operating system (GPOS) If this interface option is used with a GPOS, only operation of the serial port(s) is supported and the firmware update function cannot be used. Panel PC 3100 panel mount device User's manual V 2.10...
Page 179: 5Accif02.Fpsc-000
16550-compatible, 16-byte FIFO buffer Max. baud rate 115 kbit/s POWERLINK Quantity Type Type 4 Variant RJ45, shielded Transfer rate 100 Mbit/s Transfer 100BASE-TX Line length Max. 100 m between two stations (segment length) Panel PC 3100 panel mount device User's manual V 2.10...
Page 180 POWERLINK commissioning and operation For a description of the operating modes, status and node numbers of the POWERLINK interface(s), see "LED "S/E" (status/error LED)" on page 345. Panel PC 3100 panel mount device User's manual V 2.10...
Page 181 Bit timing register 1 Baud rate 1000 kbit/s 80h or 00h 500 kbit/s 81h or 01h 250 kbit/s 83h or 03h 125 kbit/s 84h or 04h 100 kbit/s 89h or 09h 50 kbit/s Panel PC 3100 panel mount device User's manual V 2.10...
Page 182 To update the firmware contained in Automation Studio, a hardware upgrade must be performed (see Project management / Workspace / Upgrades in Automation Help). Panel PC 3100 panel mount device User's manual V 2.10...
Page 183: 5Accif02.Iss0-000
Electrical properties Power consumption 1.5 W Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 60°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 184 Passive termination can normally be used by connecting the signal lines via a 120 Ω resistor at each of the two bus ends; see "Terminating resistor" for the IF card. Panel PC 3100 panel mount device User's manual V 2.10...
Page 185 Drivers for approved operating systems are available for download in the Downloads section of the B&R website (www.br-automation.com) (if required and not already included in the operating system). Approved operating systems: • Automation Runtime • Linux for B&R • Windows 10 Panel PC 3100 panel mount device User's manual V 2.10...
Page 186: 5Accif04.Fplk-000
Power consumption 1.5 W Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 55 °C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 187 To update the firmware contained in Automation Studio, a hardware upgrade must be performed (see Project management / Workspace / Upgrades in Automation Help). Panel PC 3100 panel mount device User's manual V 2.10...
Page 188: Uninterruptible Power Supply (Ups)
Battery unit 5AC901.BUPS-01 is only permitted to be operated with UPS IF option 5AC901.IUPS-01! Information: For information about installation and connecting to the UPS IF option, see section "Installing and connecting the UPS battery unit" on page 309. Panel PC 3100 panel mount device User's manual V 2.10...
Page 189: 5Ac901.Iups-00
Charging current Typ. 1 A Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 55°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 190 Temperature sensor 4.2.8.2.4 Installation This module is installed using the materials included in delivery. For additional information regarding installation, see section "Installing the interface option and DDR4 SDRAM" on page 304. Panel PC 3100 panel mount device User's manual V 2.10...
Page 191: 5Ac901.Iups-01
Charging current Typ. 0.88 A Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Operation 0 to 55°C Storage -20 to 60°C Transport -20 to 60°C Panel PC 3100 panel mount device User's manual V 2.10...
Page 192 Temperature sensor 4.2.8.3.4 Installation This module is installed using the materials included in delivery. For additional information regarding installation, see section "Installing the interface option and DDR4 SDRAM" on page 304. Panel PC 3100 panel mount device User's manual V 2.10...
Page 193: 5Ac901.Bups-00
E115267 Industrial control equipment HazLoc cULus HazLoc E180196 Industrial control equipment for hazardous locations Class I, Division 2, Groups ABCD, T4 Product family certification Electrical properties Nominal voltage 24 V Panel PC 3100 panel mount device User's manual V 2.10...
Page 194 4.2.8.4.4 Service life The following diagram shows the relationship between ambient temperature and service life. 50% reduction in service life expectancy if temperature increased by 8°C 33°C Ambient temperature [°C] Panel PC 3100 panel mount device User's manual V 2.10...
Page 195 Neutralized mud must be stored in closed containers and stored / disposed of in accordance with applicable reg- ulations. After neutralization and inspection, larger spills diluted with water must be disposed of in accordance with applicable regulations. Panel PC 3100 panel mount device User's manual V 2.10...
Page 196 • A sufficient supply of water must be located nearby. • Prevent damage to containers in which batteries and rechargeable batteries are stored and transported. • Keep away from fire, sparks and heat. Panel PC 3100 panel mount device User's manual V 2.10...
Page 197: 5Ac901.Bups-01
Typ. 5 hours Certifications UKCA cULus E115267 Industrial control equipment HazLoc cULus HazLoc E180196 Industrial control equipment for hazardous locations Class I, Division 2, Groups ABCD, T4 Product family certification Panel PC 3100 panel mount device User's manual V 2.10...
Page 198 4.2.8.5.4 Service life The following diagram shows the relationship between ambient temperature and service life. Ambient temperature [°C] Panel PC 3100 panel mount device User's manual V 2.10...
Page 199 Neutralized mud must be stored in closed containers and stored / disposed of in accordance with applicable reg- ulations. After neutralization and inspection, larger spills diluted with water must be disposed of in accordance with applicable regulations. Panel PC 3100 panel mount device User's manual V 2.10...
Page 200 • A sufficient supply of water must be located nearby. • Prevent damage to containers in which batteries and rechargeable batteries are stored and transported. • Keep away from fire, sparks and heat. Panel PC 3100 panel mount device User's manual V 2.10...
Page 201: 5Caups.xxxx-01
Yes, but applies only if all components installed in the complete system have this certification and the complete system bears the corresponding mark. At an ambient temperature of 20°C. Tightening torque: Min. 0.4 Nm, max. 0.5 Nm Panel PC 3100 panel mount device User's manual V 2.10...
Page 202 • Wire cross section • Sensor line 4.2.8.6.4 Installation For information about connecting the cable to the battery unit, see section "Installing and connecting the UPS battery unit" on page 309. Panel PC 3100 panel mount device User's manual V 2.10...
Page 203: Side Covers
Humidity: B (up to 100%) Vibration: A (0.7 g) EMC: B (bridge and open deck) ENV3 EC31B Temperature: 5 - 55°C Vibration: 0.7 g EMC: Bridge and open deck Product family certification Panel PC 3100 panel mount device User's manual V 2.10...
Page 204 Yes, but applies only if all components installed in the complete system have this certification and the complete system bears the corresponding mark. Yes, but applies only if all components installed in the complete system have this certification and are listed on the associated DNV certificate for the product family. Panel PC 3100 panel mount device User's manual V 2.10...
Page 205: Key Covers
Yes, but applies only if all components installed in the complete system have this certification and the complete system bears the corresponding mark. Yes, but applies only if all components installed in the complete system have this certification and are listed on the associated DNV certificate for the product family. Panel PC 3100 panel mount device User's manual V 2.10...
Page 206: Cfast Cards
Technical data 4.2.11 CFast cards Additional information about compatible CFast cards is available in aggregate data sheet for CFast cards on the B&R website. Panel PC 3100 panel mount device User's manual V 2.10...
Page 207: Installation And Wiring
If the load-bearing capacity of the mounting surface is insufficient, or if the fastening material is inadequate or incorrect, the device may fall and become damaged. • To avoid overheating, the device is not permitted to be placed near other heat sources. Panel PC 3100 panel mount device User's manual V 2.10...
Page 208: Installing A Panel Pc With An Ap9X3 Panel
5.1.1 Installing a Panel PC with an AP9x3 panel The Panel PC 3100 with AP9x3 panel is installed in the installation cutout using retaining clips. The number of retaining clips depends on the panel.
Page 209 4. Secure the retaining clips by alternately tightening the mounting screws with a 2.5 mm hex screwdriver (max. tightening torque 1 Nm). Thickness of the wall or control cabinet Minimum Maximum "Installation diagrams" on page 32 Panel PC 3100 panel mount device User's manual V 2.10...
Page 210: Installing The Automation Panel 1000 With Retaining Clips
Installation and wiring 5.1.2 Installing the Automation Panel 1000 with retaining clips The Panel PC 3100 with AP1000 panel is installed in the installation cutout using retaining clips. The number of retaining clips depends on the panel. The device must be installed on a flat, clean and burr-free surface since tightening screws on an uneven area can result in damage to the display or the ingress of dust and water.
Page 211: Installing The Automation Panel 1000 With Clamping Blocks
"Installation diagrams" on page 32 5.1.3 Installing the Automation Panel 1000 with clamping blocks The Panel PC 3100 with AP1000 panel is installed in the installation cutout using clamping blocks. The number of clamping blocks depends on the panel. The device must be installed on a flat, clean and burr-free surface since tightening screws on an uneven area can result in damage to the display or the ingress of dust and water.
Page 212 0.5 Nm). The mounting screws push the clamping lever downwards, which in turn secures the device to the wall or control cabinet panel. Thickness of the wall or control cabinet Minimum Maximum "Installation diagrams" on page 32 Panel PC 3100 panel mount device User's manual V 2.10...
Page 213: Replacing A System Unit
7. The system unit can be reinstalled in reverse order. The max. tightening torque of the Torx screws (T10) is 0.5 Nm. Only the supplied installation materials are permitted to be used to install the system unit. Panel PC 3100 panel mount device User's manual V 2.10...
Page 214: Installation Information For Individual Deliveries / Individual Components
"UEFI BIOS options" on page 224. This may be required for the following individual components: • System unit • Interface option • Graphics option • Mass storage option • Main memory (DDR4 SDRAM) Panel PC 3100 panel mount device User's manual V 2.10...
Page 215: Connecting To The Power Grid
③ as shown in the figure below. Close the terminal contact by removing the screwdriver. It is important to pay attention to the label on the cage clamp terminal ④. 24 VDC 0 VDC Panel PC 3100 panel mount device User's manual V 2.10...
Page 216: Connecting The Power Supply To A B&R Device
1. Carry out electrostatic discharge on the housing or at the ground connection. 2. Connect the power supply connector to the B&R device and tighten the mounting screws (max. tightening torque 0.5 Nm). Panel PC 3100 panel mount device User's manual V 2.10...
Page 217: Grounding Concept - Functional Ground
• Observe the shielding concept of the conductors. All data cables connected to the device must be shielded. Legend Power supply connection +24 VDC pin 2 Central grounding point Ground connection At least 1.5 mm² At least 2.5 mm² Panel PC 3100 panel mount device User's manual V 2.10...
Page 218: Commissioning
For this specification, see the technical data of the respective cable. The maximum tightening torque of the locating screws is 0.5 Nm. Bend radius Locating screws Panel PC 3100 panel mount device User's manual V 2.10...
Page 219: Switching On The Device For The First Time
6.3.2 Switching on the device Procedure 1. Connect the power supply and switch it on (e.g. power supply unit). 2. The device is operating and boots; LED Power lights up. Panel PC 3100 panel mount device User's manual V 2.10...
Page 220: Touch Screen Calibration
The number and temperature limits vary depending on the device family. For position specifications of the temperature sensors and their maximum specified temperatures, see section "Temperature sensor positions" on page Panel PC 3100 panel mount device User's manual V 2.10...
Page 221: Evaluating Temperatures In Windows Operating Systems
Information: Loopback adapters are also available from PassMark. For additional information, see www.pass- mark.com. The following screenshots refer to PassMark BurnInTest Pro V7.1 using a PPC3100 without IF options. Panel PC 3100 panel mount device User's manual V 2.10...
Page 222 Windows as formatted drives. Option "USB" must then be deselected in the test configuration, and the USB flash drives must be configured as test devices in the disk properties. Panel PC 3100 panel mount device User's manual V 2.10...
Page 223: Evaluating The Measurement Results
• If problems occur with the ETH1 or ETH2 interface (connection abort, slow data transfer, etc.), the Ener- gy-Efficient Ethernet feature can be disabled in the driver as a possible solution. Panel PC 3100 panel mount device User's manual V 2.10...
Page 224: Software
Entries outside a specified range of values are not applied. Default values are marked bold and italic in column "Input options" in tables. Submenus are bold in column "BIOS parameter" in tables. Panel PC 3100 panel mount device User's manual V 2.10...
Page 225 Opens submenu "Hardware components" on page xyz Table 117: Main menu - Menu - Submenu(s) The 16 possible parameters are indexed from 0 to 15. Setting option "(Various)" combines different values/modes with different dependencies. Panel PC 3100 panel mount device User's manual V 2.10...
Page 226: Bios Setup And Startup Procedure
Press once: Cursor jumps to first/last line in the display area Press twice: Cursor jumps to first/last item in the menu Changes a value (step back) Changes a value (step forward) Panel PC 3100 panel mount device User's manual V 2.10...
Page 227 Defines manual values for parameters that permit this Save and close to restore the default values. Information: All manual changes are overwritten if the default values are loaded and saved. Panel PC 3100 panel mount device User's manual V 2.10...
Page 228: Boot Menu
For a detailed description of this option, see the user documentation from the operating system manufacturer. Setup utility Performs advanced configurations. "Setup utility" on page 232. Table 118: Boot menu Panel PC 3100 panel mount device User's manual V 2.10...
Page 229: Boot Manager
7.1.4 Boot manager The boot manager lists all detected and bootable legacy or UEFI media. It is possible to select the media from which the boot procedure should be performed. Panel PC 3100 panel mount device User's manual V 2.10...
Page 230: Device Manager
Default: Volume1 No special characters are permitted. Range: Max. 16 characters RAID level: RAID0 (stripe) Selects the RAID level RAID1 (mirror) Recovery Table 121: Device manager - Create RAID volume Panel PC 3100 panel mount device User's manual V 2.10...
Page 231 Table 123: Device manager - Intel® Rapid Storage Technology - RAID volume info "Disk n" is a placeholder. This BIOS parameter displays a subset of the values that are listed in more detail in the corresponding submenu. Panel PC 3100 panel mount device User's manual V 2.10...
Page 232: Setup Utility
Displays the amount of memory for channel A page 0 SODIMM 1 Displays the amount of memory for channel B page 1 Platform configuration CPUID Displays the processor ID CPU speed Displays the processor speed [MHz] Table 125: Main Panel PC 3100 panel mount device User's manual V 2.10...
Page 233 System time Adjusts the system time in the format hh:mm:ss System date Adjusts the system date in the format yyyy:mm:dd About this software Enter Displays the copyright disclaimer Table 125: Main Panel PC 3100 panel mount device User's manual V 2.10...
Page 234: Advanced
"System agent (SA) configuration" on page 250 PCH-IO configuration Enter Opens submenu "PCH-IO configuration" on page 252 PCH-FW configuration Enter Opens submenu "PCH-FW configuration" on page 257 Table 126: Advanced Panel PC 3100 panel mount device User's manual V 2.10...
Page 235 The system has full RTE support. Hyperthreading is disabled. Enabled Enabled The system has full RTE and AS support. Hyperthreading is dis- abled. Disabled Enabled The system has RTE and AS support. Hyperthreading is enabled. Panel PC 3100 panel mount device User's manual V 2.10...
Page 236 0x378 0x3E8 0x3F8 Interrupt IRQ 3 Selects the interrupt for COM D IRQ 4 IRQ 5 IRQ 7 IRQ 11 Table 129: Advanced - OEM features - Super IO (supplement) Panel PC 3100 panel mount device User's manual V 2.10...
Page 237 For graphics options only. Each start/restart increases the value by 1. The number of temperature sensors varies depending on the interface option. If no temperature sensor is available, the parameter is not displayed. Panel PC 3100 panel mount device User's manual V 2.10...
Page 238 The write amplification factor (WAF) corresponds to the amount of data actually written to memory divided by the amount of data written by the host [WAF = Data written to flash memory ÷ Data written by host]. Panel PC 3100 panel mount device User's manual V 2.10...
Page 239 Disables/Enables restoring BIOS settings from a backup during the next reboot The backup file must be stored in folder "XPCSET" (./XPCSET/) in the root directory of Enabled the target medium. Table 137: Advanced - OEM features - Backup settings Panel PC 3100 panel mount device User's manual V 2.10...
Page 240 Disables/Enables the internal USB 2.0 interface Enabled Table 138: Advanced - OEM features - USB configuration The names and scope of these parameters may vary depending on the main device and configuration. Panel PC 3100 panel mount device User's manual V 2.10...
Page 241 By default, firmware TPM (FTPM of the combination of CPU and PCH) is used. Enabled If PTT is disabled, the discrete TPM (hardware DTPM) is used. Table 139: Advanced - Chipset configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 242 Disables/Enable ACPI S3 support Enabled Native PCIE enable Disabled Native operating system PCI Express support Enabled Table 141: Advanced - OEM features - ACPI table/features control - ACPI settings Platform environment control interface Panel PC 3100 panel mount device User's manual V 2.10...
Page 243 For "initial value", see "seed" (key). This variable determines the multiplier for the CPU speed (variable * 100 MHz = CPU frequency). The range of values is specified by the system and hardware. Panel PC 3100 panel mount device User's manual V 2.10...
Page 244 Platform PL2 power Defines the platform PL2 power limit [mW] Default: 0 Range: 0 to 4,095,875 Resolution: 1/8 Table 144: Advanced - Power & Performance - CPU power management control Panel PC 3100 panel mount device User's manual V 2.10...
Page 245 Defines the IRTL value Default: 118 Range: 0 to 1023 C6/C7 long latency control (MSR 0x60C) Table 145: Advanced - Power & Performance - CPU power management control - C-states Panel PC 3100 panel mount device User's manual V 2.10...
Page 246 Disables/Enables TDP control register Enabled CTDP BIOS control Disabled Disables/Enables CTDP BIOS control Enabled Table 147: Advanced - Power & Performance - CPU power management control - Config TDP configurations Panel PC 3100 panel mount device User's manual V 2.10...
Page 247 Maximum graphics frequency (including graphic turbo) [MHz] The max. possible frequency is selected by default. Resolution: 50 MHz 100 to 1200 Mhz Table 149: Advanced - Power & Performance - GT power management control Panel PC 3100 panel mount device User's manual V 2.10...
Page 248 Disable both DIMMs Selects the mode of main memory channel B control Disables/Enables both or individual DIMMs Disable DIMM0 Disable DIMM1 Enable both DIMMs Table 150: Advanced - Memory configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 249 Defines the SelfRefresh IdleTimer in DLCK800s Default: 512 Range: 0 to 65535 Table 152: Advanced - Memory configuration - Memory thermal configuration - Memory power and thermal throttling Integrated memory controller Panel PC 3100 panel mount device User's manual V 2.10...
Page 250 Disables/Enables the graphic controller's sleep mode Enabled VDD enable Disabled Disables/Enables force VDD Enabled HDCP support Disabled Disables/Enable HDCP support Enabled Table 154: Advanced - System agent (SA) configuration - Graphics configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 251 Setting options Description DMI Vc1 control Disables/Enables DMI Vc1 Disabled Enabled DMI Vcm control Disabled Disables/Enables DMI Vcm Enabled Table 158: Advanced - System agent (SA) configuration - DMI/OPI configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 252 Enables/Disables the boot-fail pop-up (e.g. for UEFI PXE). The device tries to boot au- tomatically from the next boot device after a boot failure. Enabled Table 159: Advanced - PCH-IO configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 253 Selects the DPT preset Default: 7 Range: 0 to 10 Disabled Disables/Enables access control services extended capabilities Enabled Table 162: Advanced - PCH-IO configuration - PCI Express root port n Panel PC 3100 panel mount device User's manual V 2.10...
Page 254 Disables/Enables force LTR override Enabled PCIE1 LTR lock Disables/Enables the PCIE1 LTR lock function Disabled Enabled PCH PCIe CLKREQ# Table 162: Advanced - PCH-IO configuration - PCI Express root port n Panel PC 3100 panel mount device User's manual V 2.10...
Page 255 Use RST legacy OROM Disabled Disables/Enables rapid storage technology legacy option ROM for active CSM Enabled Table 164: Advanced - PCH-IO configuration - SATA and RST configuration - Software feature mask configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 256 Disabled Disables/Enables audio digital signal processing Enabled PME enable Disabled Disables/Enables PME wake of HD audio controller during POST Enabled Table 166: Advanced - PCH-IO configuration - HD audio configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 257 Displays the PTT capability and status PTP aware OS Selects whether the operating system used is PTP-capable or not PTP aware Not PTP aware Table 169: Advanced - PCH-FW configuration - PTT configuration Panel PC 3100 panel mount device User's manual V 2.10...
Page 258: Security
Table 171: Security - Storage password setup page Displays the manufacturer ID of the CFast card in the corresponding CFast slot. 2 CFast card slots are available. They are indexed from 1 to 2. Panel PC 3100 panel mount device User's manual V 2.10...
Page 259 Set storage password String Sets the HDD password Set master Hdd password String Sets the master HDD password Table 172: Security - Storage password setup page - CFast name n Panel PC 3100 panel mount device User's manual V 2.10...
Page 260: Power
Disabled Disables/Enables the IFn standby power Enabled Always-on Displays the always-on state Set always-on Disabled Disables/Enables always-on Enabled Table 173: Power Depends on the configuration (max. 2 expansion options possible). Panel PC 3100 panel mount device User's manual V 2.10...
Page 261: Boot
Enable to boot EFI devices before legacy devices. Disable to boot legacy devices before Enabled EFI devices. Timeout Delay time until the boot list is processed [s] Default: 0 Range: 0 to 99 Table 174: Boot Panel PC 3100 panel mount device User's manual V 2.10...
Page 262 BIOS parameter Setting options Description Enter, then: Defines the boot sequence ► Keyboard: F5/F6 ► Touch screen: Move items at the gray arrows Table 176: Boot - EFI - EFI Panel PC 3100 panel mount device User's manual V 2.10...
Page 263 Enter, then: Defines the boot sequence ► Keyboard: F5/F6 ► Touch screen: Move items at the gray arrows Table 181: Boot - Legacy - Hard disk drive - Hard disk drive Panel PC 3100 panel mount device User's manual V 2.10...
Page 264: Exit
Load optimal defaults Enter Loads system-optimized default values Load custom defaults Enter Loads user-specific default values Save custom defaults Enter Saves user-specific default values Discard changes Enter Discards changes Table 182: Exit Panel PC 3100 panel mount device User's manual V 2.10...
Page 265: Upgrade Information
7.2.2 PC firmware upgrade With Firmware upgrade (MTCX, SDLT, SDL4T), it is possible to update the firmware of several controllers (MTCX, SDLT, SDL4T) depending on the variant of the Panel PC system. Panel PC 3100 panel mount device User's manual V 2.10...
Page 266: Procedure In Windows (Adi Control Center)
FAT32 (e.g. CFast card or USB flash drive). The following figure shows the view of a suitable data storage medium with an upgrade. Panel PC 3100 panel mount device User's manual V 2.10...
Page 267: Firmware Upgrade With Automation Runtime
4. Click on the desired update under PC firmware or Panel firmware. The dialog box opens. 5. Enter the name of the firmware file or select a file under "Filename". 6. Execute file with Open. Panel PC 3100 panel mount device User's manual V 2.10...
Page 268: Procedure In The Efi Shell
The power supply to the PC or Automation Panel must be switched off and on again for the new firmware to take effect and the updated version to be displayed. Panel PC 3100 panel mount device User's manual V 2.10...
Page 269: Raid Configuration
Figure 8: Advanced - PCH-IO configuration - SATA and RST configuration - SATA mode selection Figure 9: Configured SATA mode selection for RAID volume Information: This setting is required for legacy and UEFI boot mode. Panel PC 3100 panel mount device User's manual V 2.10...
Page 270: Legacy Raid
Cursor (↑, ↓) Navigation in the menu and between objects. Enter Selects an item or opens a submenu. Returns to the previous menu. Table 183: BIOS-relevant keys in the RAID Configuration Utility Panel PC 3100 panel mount device User's manual V 2.10...
Page 271: Create Raid Volume
This setting is only possible if RAID level is set to Recovery. This setting is only possible if RAID level is set to RAID0(Stripe). This setting is only possible if RAID level is set to Recovery. Panel PC 3100 panel mount device User's manual V 2.10...
Page 272: Delete Raid Volume
Actions will result in change from Continuous Update mode to On-Request. [ ]select [ESC]-Previous Menu [ENTER]-Select ¯ Figure 14: RAID recovery Note: Changes in this menu affect the synchronization mode. Panel PC 3100 panel mount device User's manual V 2.10...
Page 273: Reset Disks To Non-Raid
SFCA064GH1AD4TO- 60134158A6000058 59.6GB Member Disk Select the disks that should be reset. [ ]-Previous/Next [SPACE]-Selects [ENTER]-Selection Complete ¯ [ ]-Select [ESC]-Exit [ENTER]-Select Menu ¯ Figure 15: Resetting the RAID volume Panel PC 3100 panel mount device User's manual V 2.10...
Page 274: Uefi Raid
Table 185: Keys in the device manager 7.3.2.2 Create RAID volume RAID volumes can be created via submenu "Create RAID volume" on page 230 in section "Intel® Rapid Storage Technology" on page 230. Panel PC 3100 panel mount device User's manual V 2.10...
Page 275 If storage media of different sizes are used, this is limited to the smaller medium. Synchronization: Continuous Selects the synchronization mode On request Table 186: Device manager - Create RAID volume Figure 18: Intel® Rapid Storage Technology with created RAID volume (RAID1) Panel PC 3100 panel mount device User's manual V 2.10...
Page 276: Delete Raid Volume
For RAID volumes associations in recovery mode, there is the option to enable or disable only the recovery disk or master disk. This option is available in menu "RAID volume info" on page 231. Figure 20: RAID recovery Note: Changes in this menu affect the synchronization mode. Panel PC 3100 panel mount device User's manual V 2.10...
Page 277: Reset Disks To Non-Raid
• Linux for B&R 10 • Linux for B&R 9 No guarantee can be given for multi-touch or single-touch operation, compatibility and functionality for operation with other operating systems and/or individual touch screen drivers. Panel PC 3100 panel mount device User's manual V 2.10...
Page 278: Operating Systems
• The version installed by B&R contains optimized settings for operation in an industrial environment. These are described in detail in the Windows 10 IoT Enterprise 2019 LTSC working guide. This contains infor- mation about installing languages, enabling lockdown and other features. Panel PC 3100 panel mount device User's manual V 2.10...
Page 279: Installation
B&R website (www.br-automation.com). It is important to ensure that "Unified Write Filter (UWF)" is disabled. Information: Necessary drivers must be downloaded from the B&R website, not from manufacturer websites. Panel PC 3100 panel mount device User's manual V 2.10...
Page 280: Activation
Windows requires SVGA resolution (800 x 600) or higher per Microsoft requirements to activate full operation of the Windows interface (e.g. with system dialog boxes). A lower resolution can be selected for applications. Panel PC 3100 panel mount device User's manual V 2.10...
Page 281: Windows 10 Iot Enterprise 2016 Ltsb
Configurable (disabled by default in the image by the UWF) Defragmentation service ✓ (Disabled when enabling the UWF) Additional embedded lockdown functions Assigned access Configurable Table 191: Device functions in Windows 10 IoT Enterprise 2016 LTSB Panel PC 3100 panel mount device User's manual V 2.10...
Page 282 Function Windows 10 IoT Enterprise 2016 LTSB AppLocker Configurable Shell Launcher Configurable ✓ Unified Write Filter Keyboard Filter Configurable Table 191: Device functions in Windows 10 IoT Enterprise 2016 LTSB Panel PC 3100 panel mount device User's manual V 2.10...
Page 283: Installation
Windows 10 IoT Enterprise 2015 LTSB (Microsoft reserves the right to make technical changes without notice). Information: It is not required to enter a product key for activation. Panel PC 3100 panel mount device User's manual V 2.10...
Page 284: Characteristics, Limitations
Windows requires SVGA resolution (800 x 600) or higher per Microsoft requirements to activate full operation of the Windows interface (e.g. with system dialog boxes). A lower resolution can be selected for applications. Panel PC 3100 panel mount device User's manual V 2.10...
Page 285: Linux For B&R 10 (Gnu/Linux)
Linux for B&R 10 is preinstalled on the desired data storage medium (e.g. CFast card). 7.5.3.6 Drivers The operating system contains all drivers necessary for operation. The current version of B&R-specific drivers can be downloaded and installed from the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 286: Linux For B&R 9 (Gnu/Linux)
Detailed instructions about Linux for B&R 9 can be downloaded from the Downloads section of the B&R website (www.br-automation.com). 7.5.4.5 Installation Linux for B&R 9 is preinstalled on the desired data storage medium (e.g. CFast card). 7.5.4.6 Drivers The operating system contains all drivers necessary for operation. Panel PC 3100 panel mount device User's manual V 2.10...
Page 287 Software The current version of B&R-specific drivers can be downloaded and installed from the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 288: Automation Software
The following table provides an overview of which Automation Runtime software components are supported by the device. Target system B&R Hypervisor ARemb ARemb Terminal (TG only) ARwin (TG only) PPC3100 ARwin is no longer supported starting with Automation Runtime V4.6. Panel PC 3100 panel mount device User's manual V 2.10...
Page 289: Automation Runtime
Enabled in BIOS and parameter Boot - EFI device first must be set to Disabled. Information: ARwin is no longer supported starting with Automation Runtime V4.6. Information: For detailed information, see Automation Help or the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 290: Information About Operation With Automation Runtime
Single-core operation with 2100 MHz CPU frequency and 450 MHz Gfx frequency xPC3100 i7-7600U Single-core operation with 1600 MHz CPU frequency and 800 MHz Gfx frequency Single-core operation with 2100 MHz CPU frequency and 450 MHz Gfx frequency Panel PC 3100 panel mount device User's manual V 2.10...
Page 291: B&R Hypervisor
Windows version, B&R Hypervisor is completely independent of the version of the operating systems used. System requirements The following minimum software versions are required to operate B&R Hypervisor on the Panel PC 3100: • ARemb upgrade AR B4.45 • Automation Studio V4.4.5 •...
Page 292: Mapp Technology
Complex algorithms are easy to master. Programmers can focus entirely on the machine process. Information: For detailed information, see Automation Help or the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 293: Automation Device Interface (Adi)
• Changing the user serial ID For a detailed description, see the user documentation for the ADI driver. Information: The functions available in the ADI Control Center depend on the device family. Panel PC 3100 panel mount device User's manual V 2.10...
Page 294: Adi Development Kit
For a detailed description of how to use ADI functions, see Automation Help. The ADI Development Kit can be downloaded at no cost from the Downloads section of the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 295: Adi .Net Sdk
For a detailed description of how to use ADI functions, see Automation Help. The ADI .NET SDK can be downloaded at no cost from the Downloads section of the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 296: Adi Opc Ua Server
Alternatively, the report can be created from the command line with the following command: C:\Programme\BrAutomation\Adi\System\HmiReport\BR.Hmi.Report.Cli.exe <Dateiname> If no filename is specified, a text report is created with filename "<Material number>_<Serial number>.txt". Panel PC 3100 panel mount device User's manual V 2.10...
Page 297: Key Editor
For detailed instructions about configuring keys and LEDs and installing the key configuration on the target system, see the help documentation for the Key Editor. The Key Editor and help documentation can be downloaded at no cost from the Downloads section of the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 298: Kcf Editor
For detailed instructions about configuring keys and LEDs and installing the key configuration on the target system, see the user documentation for the KCF Editor. The KCF Editor and user documentation can be downloaded at no cost from the Downloads section of the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 299: Hmi Service Center
Automation PC 810 ● Automation PC 511 ● Automation PC 510 ● Panel PC 3100 ● Panel PC 2200 ● Panel PC 1200 ● Panel PC 800 ● Power Panel 500 ● Panel PC 3100 panel mount device User's manual V 2.10...
Page 300: Maintenance
• When cleaning, areas with adhesive labels and product information should be left out to avoid damage. Information: Displays with a touch screen should be cleaned at regular intervals. Panel PC 3100 panel mount device User's manual V 2.10...
Page 301: Changing The Battery
The battery is not permitted to be held by its edges. Insulated tweezers may also be used to insert the battery. When reinserting, pay attention to the polarity. The positive terminal is marked on the adapter; this must match the positive terminal of the battery. Panel PC 3100 panel mount device User's manual V 2.10...
Page 302 6. Reconnect the power supply to the B&R industrial PC (connect the power connector). 7. Set the date and time in BIOS again. Warning! Lithium batteries are hazardous waste! Used batteries must be disposed of in accordance with local regulations. Panel PC 3100 panel mount device User's manual V 2.10...
Page 303: Replacing Cfast Cards
3. Press the ejector next to the card slot. The CFast card is ejected and can be replaced. 4. After replacing, re-secure the cover of the CFast card slot. The max. tightening torque of the screw is 0.55 Nm. Panel PC 3100 panel mount device User's manual V 2.10...
Page 304: Installing The Interface Option And Ddr4 Sdram
2. Carry out electrostatic discharge on the housing or at the ground connection. 3. Loosen the Torx screws (T10) of the cover. Their number may vary depending on the system unit. 4. Remove the cover. Panel PC 3100 panel mount device User's manual V 2.10...
Page 305 IF option or the associated data sheet of the module starting on page 147). The interface option must be mounted inside the housing in order to be installed properly. Panel PC 3100 panel mount device User's manual V 2.10...
Page 306 The module can be inserted or replaced. The locking mechanism engages and locks the SDRAM module when properly mounted. 7. Fasten the interface option to the housing using the Torx screws (T10). Figure 23: Securing the interface option Panel PC 3100 panel mount device User's manual V 2.10...
Page 307 Maintenance 8. Install the cover. 9. Install the cover on the housing using the Torx screws (T10). Panel PC 3100 panel mount device User's manual V 2.10...
Page 308: Installing M.2 Mass Storage Devices
Installation in an APC3100/PPC3100 must be carried out according to the description in section "Installing the interface option and DDR4 SDRAM" on page 304. Installation takes place in slot IF option 3. Panel PC 3100 panel mount device User's manual V 2.10...
Page 309: Installing And Connecting The Ups Battery Unit
(max. tightening torque 0.35 Nm). 7. Connect the 4-pin screw clamp terminal block to the UPS IF option and tighten the two screws with a screw- driver (max. tightening torque 0.4 Nm). Panel PC 3100 panel mount device User's manual V 2.10...
Page 310: Permissible Mounting Orientations
Maintenance 8.5.1 Permissible mounting orientations The UPS battery unit is only permitted to be installed as illustrated below. Panel PC 3100 panel mount device User's manual V 2.10...
Page 311: User Tips For Increasing The Service Life Of The Display
• Use screensavers. 8.7 Pixel errors Information: Displays can contain faulty pixels (pixel errors) due to the manufacturing process. They are not grounds for initiating a complaint or warranty claim. Panel PC 3100 panel mount device User's manual V 2.10...
Page 312: Repairs/Complaints And Replacement Parts
Repairs are therefore only permitted to be carried out by authorized qualified personnel at the manufacturer's premises. To process a repair/complaint, a repair order or complaint must be created via the B&R Material Return Portal on the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 313: Accessories
2.0 Nm - 1x hex head bit 2.5, length 89 mm - 1x hex head bit 3.0, length 89 mm - 1x hex head bit 5.0, length 89 mm - 1x Torx 10 bit, length 90 mm - 1x Torx 20 bit, length 89 mm Panel PC 3100 panel mount device User's manual V 2.10...
Page 314: 0Tb103.9X
Yes, but applies only if all components installed in the complete system have this certification and are listed on the associated DNV certificate for the product family. The cage clamp terminal block cannot be used side by side. The respective limit data of the I/O modules must be taken into account! Panel PC 3100 panel mount device User's manual V 2.10...
Page 315: Terminal Block For If Options
Wire end sleeves with plastic covering 0.14 to 1 mm² Solid wires 0.14 to 1.5 mm² Fine-stranded wires 0.14 to 1.5 mm² With wire end sleeves 0.14 to 1.5 mm² Panel PC 3100 panel mount device User's manual V 2.10...
Page 316 Yes, but applies only if all components installed in the complete system have this certification and are listed on the associated DNV certificate for the product family. The respective limit data of the I/O modules must be taken into account! Panel PC 3100 panel mount device User's manual V 2.10...
Page 317: Terminal Block Ready Relay
Nominal voltage 300 V Nominal current 10 A Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 The respective limit data of the IF option must be taken into account! Panel PC 3100 panel mount device User's manual V 2.10...
Page 318: Replacement Cmos Batteries
Operating conditions Pollution degree per EN 61131-2 Pollution degree 2 Ambient conditions Temperature Storage -20 to 60°C Relative humidity Operation 0 to 95% Storage 0 to 95% Transport 0 to 95% Panel PC 3100 panel mount device User's manual V 2.10...
Page 319: Usb Mass Storage Device
For additional information about compatible USB mass storage devices, see the B&R website (USB mass storage devices). 9.8 Cables For additional information about compatible cables, see the B&R website (HMI cable manual). Panel PC 3100 panel mount device User's manual V 2.10...
Page 320: International And National Certifications
Electromagnetic compatibility (EMC) - Part 6-4: Generic standards - Emission stan- dard for industrial environments Information: Declarations of conformity are available on the B&R website under Downloads > Certificates > Decla- rations of conformity. Panel PC 3100 panel mount device User's manual V 2.10...
Page 321: Certifications
Eurasian Customs Union (based on EU conformity). 10.2.3 KC Products with this mark are tested by an accredited test laboratory and permitted to be introduced into the Korean market (based on EU conformity). Panel PC 3100 panel mount device User's manual V 2.10...
Page 322: Ukca
Products with this mark are tested by an accredited test laboratory and certified by the ACMA. The mark is valid for Australia/Oceania and simplifies the certification of your machines and systems in this economic area (based on EU conformity). Panel PC 3100 panel mount device User's manual V 2.10...
Page 323: Dnv Certification
Certificates with specifications for permissible environmental conditions as well as a list of revisions from which the certification applies to individual devices are avail- able on the B&R website (Downloads > Certificates > Maritime). Panel PC 3100 panel mount device User's manual V 2.10...
Page 324: Ul Haz. Loc. Certification
Risk of explosion: Accessories are not permitted to be connected or disconnected when the power is switched on unless the area is considered nonhazardous and is free of ignitable concentrations! Risk of explosion: Replacing components may impair eligibility for Class I, Division 2! Panel PC 3100 panel mount device User's manual V 2.10...
Page 325: Servicing, Disturbances And Disassembly
Failure to follow this instruction can result in death, serious bodily injury or damage to property! Danger ! Le non-respect de ces instructions peut entraîner des blessures graves ou mortelles! Panel PC 3100 panel mount device User's manual V 2.10...
Page 326: Usb Connection With The Panel Pc 3100
10.2.11.5.1 Introduction The information below describes the use of USB peripheral devices on USB interfaces 1, 2, 3 and 4 of the B&R Panel PC 3100 in hazardous locations Class I, Division 2, Groups A, B, C and D. Danger! EXPLOSION HAZARD •...
Page 327 The B&R device is suitable for use in Class I, Division 2, Groups A, B, C and D areas. It also provides nonincendive field wiring for devices in Class I, Division 2, Groups A, B, C and D. Panel PC 3100 panel mount device User's manual V 2.10...
Page 328: Usb Connection With The Automation Panel 1000
) for the connected device must be greater than or equal to C and L Cable Cable for the nonincendive device with field wiring. The nonincendive device with field wiring must meet the following criteria: Panel PC 3100 panel mount device User's manual V 2.10...
Page 329 The B&R device is suitable for use in Class I, Division 2, Groups A, B, C and D areas. It also provides nonincendive field wiring for devices in Class I, Division 2, Groups A, B, C and D. Panel PC 3100 panel mount device User's manual V 2.10...
Page 330: Usb Connection With Optional Displayport Graphics Option
The information below describes the use of USB peripheral devices on the USB interface of the DisplayPort graph- ics option in the B&R Panel PC 3100 in hazardous locations Class I, Division 2, Groups A, B, C and D. Danger! EXPLOSION HAZARD •...
Page 331 The B&R device is suitable for use in Class I, Division 2, Groups A, B, C and D areas. It also provides nonincendive field wiring for devices in Class I, Division 2, Groups A, B, C and D. Panel PC 3100 panel mount device User's manual V 2.10...
Page 332: Environmentally Friendly Disposal
Operating and monitoring devices Uninterruptible power supplies Batteries and rechargeable batteries Cables Paper/Cardboard packaging Paper/Cardboard recycling Plastic packaging material Plastic recycling Disposal must be carried out in accordance with applicable legal regulations. Panel PC 3100 panel mount device User's manual V 2.10...
Page 333: Appendix A Abbreviations
Used in technical data tables if there is currently no value for specific technical data. The value will be supplied later. MTBF Mean time between failures The expected value of the operating time between two consecutive failures. Panel PC 3100 panel mount device User's manual V 2.10...
Page 334: Appendix B Maintenance Controller Extended (Mtcx)
. The version can be read in BIOS or in approved Microsoft Windows operating systems using the ADI Control Center. Can be downloaded from the Downloads section of the B&R website (www.br-automation.com). Panel PC 3100 panel mount device User's manual V 2.10...
Page 335: Appendix C Viewing Angles
Appendix C Appendix C Viewing angles For viewing angle specifications (R, L, U, D) of the display types, see the technical data of the individual compo- nents. 6 o'clock direction Panel PC 3100 panel mount device User's manual V 2.10...
Page 336: Appendix D Chemical Resistance
• AP9x3 single-touch panels < revision B8 were manufactured with an aluminum panel overlay. Touch screen Panel overlay Multi-touch panels • AP9x3 and AP1000 multi-touch panels are equipped with a continuous glass surface. Touch screen Panel PC 3100 panel mount device User's manual V 2.10...
Page 337: Autotex Panel Overlay (Polyester)
• Sodium bisulphate • Dibutyl phthalate Per DIN 42115 Part 2, the panel overlay is resistant to exposure to glacial acetic acid for less than one hour without visible damage. Panel PC 3100 panel mount device User's manual V 2.10...
Page 338: Aluminum Panel Overlay
• Diesel • Sodium hydroxide <40% • Skydrol • Acetic acid <50% • Petroleum The coated aluminum front is not resistant to the following chemicals: • Acetone • Ethyl acetate Panel PC 3100 panel mount device User's manual V 2.10...
Page 339: Touch Screen
• Water • Hydrogen chloride <6% • Methylbenzene • White wine vinegar • Coca-Cola • Methyl ethyl ketone • Windex Original • Dimethylbenzene • Naphtha • Ethanol • Nitric acid <70% Panel PC 3100 panel mount device User's manual V 2.10...
Page 340: Appendix E Touch Screen
E.1.2 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 341: Touch Screen (Multi-Touch Generation 2)
E.2.3 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 342: Touch Screen (Multi-Touch Generation 3)
E.3.3 Temperature/Humidity diagram RH [%] T [°C] -50 -40 -30 -20 -10 Diagram legend Operation T [°C] Temperature in °C Storage and transport RH [%] Relative humidity (RH) in percent and non-condensing Panel PC 3100 panel mount device User's manual V 2.10...
Page 343: Appendix F Cable Data
Pair shielding with aluminum foil Cable cross section 1x 0.34 mm² (22AWG/19), tinned copper stranded wire Wire insulation Conductor resistance ≤59 Ω/km Outer jacket Material PUR compound Properties Halogen-free Cable shield Tinned copper wire Panel PC 3100 panel mount device User's manual V 2.10...
Page 344: Rs485 - Bus Length And Cable Type
Pair shielding with aluminum foil Cable cross section 1x 0.34 mm² (22AWG/19), tinned copper stranded wire Wire insulation Conductor resistance ≤59 Ω/km Outer jacket Material PUR compound Properties Halogen-free Cable shield Tinned copper wire Panel PC 3100 panel mount device User's manual V 2.10...
Page 345: Appendix G Powerlink
BASIC_ETHERNET. If POWERLINK communication is detected before this time expires, however, the interface immediately enters mode PRE_OPERATIONAL_1. Table: LED "S/E" - Interface state (interface in POWERLINK mode) Panel PC 3100 panel mount device User's manual V 2.10...
Page 346 MN. Table: LED "S/E" - Interface state (interface in POWERLINK mode) Blink times Triple flash 1000 Double flash 1000 Single flash 1000 Blinking Flickering All times in ms Panel PC 3100 panel mount device User's manual V 2.10...
Page 347: System Stop Error Codes
240. If the POWERLINK node is operated as a controlled node (CN), a node number from 1 to 239 can be set in the POWERLINK configuration in Automation Studio. Panel PC 3100 panel mount device User's manual V 2.10...
Page 348: Appendix H Reading Led Status Indicators
Before opening/removing covers, the device must be disconnected from the power supply. The LED status indicators of installed IF options on xPC3100 devices are visible during operation through ventilation slots in the following area. Panel PC 3100 panel mount device User's manual V 2.10...

B&R PC 3100 User Manual

Quick Links

Related Manuals for B&R PC 3100

Summary of Contents for B&R PC 3100