Fuse; Fuse Removal; Fuse Installation - Club Car Carryall 550 2015 Maintenance And Service Manual

ELECTRICAL COMPONENTS: PEDAL-START GAS
VEHICLE
5. Connect battery and spark plug wire(s). See Connecting the Battery – Gasoline Vehicles, Section 1, Page 1-4.

FUSE

See General Warnings on page 1-1.
ATC-style fuses are located inside the electrical component box near the battery.
ATM-style fuses are located on the main wire harness in front of the engine.
TESTING THE FUSE
See Test Procedure 2 – Fuses on page 18-19.

FUSE REMOVAL

1. Disconnect battery. See Disconnecting the Battery – Gasoline Vehicles, Section 1, Page 1-4.
2. ATC Fuse Only: Remove electrical component box cover cover.
ATM Fuse Only: Remove fuse holder cover.
3. Remove the fuse from the fuse block.

FUSE INSTALLATION

1. Install the fuse. See following WARNING.
WARNING
• If a fuse is blown, determine the cause of the failure and make necessary repairs before installing a
new fuse. Use the appropriately rated fuse; if a fuse with a higher amp rating is used, damage to the
vehicle electrical system may occur.
2. ATC Fuse Only: Install the snap-on electrical box cover by pressing down firmly on all corners and install
the screw, tightening to 18 in·lb (2 N·m).
ATM Fuse Only: Install the fuse holder cover.
3. Connect battery. See Connecting the Battery – Gasoline Vehicles, Section 1, Page 1-4.
2015 Carryall 550 Maintenance and Service Manual
20
Fuse
Page 20-17