The Charge Circuit; Onboard Charger Operation - Club Car Carryall 550 2015 Maintenance And Service Manual

QUIQ HIGH FREQUENCY CHARGER
Battery Charger Algorithms
CHARGER MODEL (PART NUMBER)
912–4854–04
912–4854–04

THE CHARGE CIRCUIT

The charge circuit consists of the onboard charger, batteries and charger information light (Figure 15-2, Page 15-3).
AC Cord
2979.eps

ONBOARD CHARGER OPERATION

DANGER
– Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and
service area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full face
shield and rubber gloves when working on or near batteries.
– The charging area must be ventilated. Hydrogen level in the air must never exceed 2%. The total
volume of air in the charging area must be changed five times per hour. Exhaust fans should be
located at the highest point of the roof. Contact a local HVAC engineer.
– Do not charge the vehicle batteries with the vehicle covered or enclosed. Any enclosure or
cover should be removed or unzipped and pulled back when batteries are being charged. An
accumulation of hydrogen gas could result in an explosion.
– Risk of electric shock. Connect charger power cord to an outlet that has been properly installed
and grounded in accordance with all local codes and ordinances. A grounded outlet is required
to reduce risk of electric shock; do not use ground adapters or modify plug.
DANGER CONTINUED ON NEXT PAGE
ALGORITHM
algorithm # 72
algorithm # 3
SOLID STATE SPEED
To Main
Vehicle
Harness
Gray
Connector
ONBOARD
CHARGER
Figure 15-2 Charge Circuit
2015 Carryall 550 Maintenance and Service Manual
BATTERY TYPE
JCI
Trojan
CONTROLLER
14 GA. BLACK
6 GA. RED
14 GA. RED
Solenoid
+
BATTERIES
Fuse
Onboard Charger Operation
B–
TERMINAL
–
6 GA. BLACK
15
Page 15-3