Club Car Carryall 550 2015 Maintenance And Service Manual page 455

armature ground test (starter/genera-
tor) ................................................................. 20-7
spark plug......................................................... 22-6
throttle body .................................................23-1, 23-3
installation ........................................................ 23-4
removal ............................................................ 23-3
tie rod and drag link
installation ........................................................ 7-13
removal ............................................................ 7-13
tilt bed
installation ........................................................ 4-13
removal ............................................................ 4-13
tire
installation .......................................................... 8-4
pressure ............................................................. 8-1
removal .............................................................. 8-3
repair.................................................................. 8-3
tools
see service tools ............................................... 26-3
torque converter
troubleshooting ................................................. 25-1
Tow/Run switch .................................................... 12-2
installation ........................................................ 13-4
removal ............................................................ 13-4
testing ............................................................ 12-18
transaxle
installation ...................................................... 26-12
lubrication ......................................................... 26-2
removal ............................................................ 26-9
service.............................................................. 26-2
transaxle, type g
assembly .......................................................... 17-9
axle bearing ...................................................... 17-4
axle shaft
installation ..................................................... 17-4
removal ......................................................... 17-1
disassembly...................................................... 17-7
inspection ......................................................... 17-7
installation .......................................................17-11
lubrication ......................................................... 17-1
oil seal
installation ..................................................... 17-4
removal ......................................................... 17-1
removal ............................................................ 17-5
troubleshooting..................................................... 12-8
CDT handheld programmer...............................11-30
torque converter ................................................ 25-1
troubleshooting guide 1...................................... 12-9
troubleshooting guide 2.................................... 12-12
troubleshooting guide
gasoline vehicle ................................................ 18-2
V
Visage
connector, 4-pin
see test procedures............................ 12-42, 18-43
voltage limiter
testing ............................................................ 18-42
voltage regulator
installation ...................................................... 20-12
removal .......................................................... 20-12
testing ............................................................ 18-31
W
walk away braking ................................................ 12-2
walk away braking relay
testing ............................................................ 12-41
water level
see batteries, electrolyte level .......................... 14-10
wheel
installation .......................................................... 8-1
removal .............................................................. 8-1
see also tire ........................................................ 8-4
wheel bearing
installation ........................................................ 26-7
removal ............................................................ 26-7
wiring diagram – key-start gasoline
vehicle ............................................................... 19-2
wiring diagram – pedal-start gasoline
vehicle ............................................................... 18-8
wiring diagrams .................................................... 12-4
2015 Carryall 550 Maintenance and Service Manual
INDEX
Page i-7