Club Car Carryall 550 2015 Maintenance And Service Manual page 286

18
Troubleshooting Guide
TROUBLESHOOTING GUIDE
SYMPTOM
Starter fails to operate.
Starter/generator does not charge battery.
Transmission does not engage or disengage
smoothly.
TABLE CONTINUED ON NEXT PAGE
Page 18-6 2015 Carryall 550 Maintenance and Service Manual
TROUBLESHOOTING AND ELECTRICAL SYSTEM:
POSSIBLE CAUSES
Neutral lockout switch is in the MAINTENANCE
position
Fuse is blown
Battery is dead
Starter control circuit is not operating
Starter/generator failed
Starter solenoid failed
Accelerator pedal limit switch failed
Key switch failed
Neutral lockout limit switch failed
Loose or broken wire in starter/generator
circuit
Cylinder and/or crankcase flooded with fuel
Loose or broken wire in the starter/ generator
circuit
Generator field coil is shorted
Brushes are worn or commutator is dirty
Starter/generator belt is loose or slipping
Voltage regulator failed
Battery failed
Transmission shifter linkage is binding or is
out of adjustment
Insufficient (low) level of lubricant or wrong
type of lubricant in transmission
Internal gears are damaged or worn
Dog clutch jammed or broken
PEDAL-START GAS VEHICLE
CORRECTIVE ACTION
Place switch in the OPERATE position.
Test Procedure 2 – Fuses
Test Procedure 1 – Battery
Test Procedure 5 – Key Switch (Start Circuit)
Test Procedure 12 – Starter/Generator (Starter
Function)
Test Procedure 8 – Solenoid
Test Procedure 7 – Accelerator Pedal Limit
Switch – Pedal-Start Vehicles Only
Test Procedure 5 – Key Switch (Start Circuit)
Test Procedure 10 – Neutral Lockout Limit
Switch – Pedal-Start Vehicles Only
See Section 20 – Electrical Components:
Pedal-Start Gas Vehicle. Starter/Generator on
page 20-1
See Section 23 – Fuel System: Gasoline
Vehicles.
Test Procedure 11 – Starter/Generator
(Generator Function)
Test Procedure 11 – Starter/Generator
(Generator Function)
See Section 20 – Electrical Components:
Pedal-Start Gas Vehicle. Starter/Generator on
page 20-1
See Section 20 – Electrical Components:
Pedal-Start Gas Vehicle. Belt Tension
Adjustment on page 20-11
Test Procedure 13 – Voltage Regulator
Test Procedure 1 – Battery
See Section 26 – Transaxle (ED65): Gasoline
Vehicles.
See Section 26 – Transaxle (ED65): Gasoline
Vehicles.
See Section 26 – Transaxle (ED65): Gasoline
Vehicles.
See Section 26 – Transaxle (ED65): Gasoline
Vehicles.