Every 10 Hours Or Daily; Checking Engine Oil Level - MacDon M1170NT5 Operator's Manual

5.7 Every 10 Hours or Daily

Complete the following maintenance tasks every 10 hours of operation or daily, whichever occurs first.
• Check the engine oil level. For instructions, refer to
• Check the engine coolant level. For instructions, refer to
• Check the hydraulic oil level. For instructions, refer to
• Check the tire inflation. For instructions, refer to
• Check the hydraulic hoses and lines for leaks. For instructions, refer to
• Drain the fuel filter water trap. For instructions, refer to
• Clean the radiator, hydraulic oil cooler, charge air cooler, and A/C condenser. For instructions, refer to
Cooler Module, page 284.
• Fill the fuel tank. For instructions, refer to
• Check the diesel exhaust fluid (DEF) level. For instructions, refer to

5.7.1 Checking Engine Oil Level

Check the engine oil level frequently and watch for any signs of leakage.
DANGER
To prevent bodily injury or death from the unexpected startup of the machine, always stop the engine and remove the
key from the ignition before leaving the operator's seat for any reason.
NOTE:
During the break-in period, a higher than usual oil consumption should be considered normal.
NOTE:
The engine oil level can be checked without opening the hood.
1. Operate the engine at low idle, and check for leaks at the filter and drain plug.
2. Shut down the engine, and remove the key from the ignition.
3. Wait about 5 minutes.
4. Locate the engine oil dipstick on the right side of the
windrower. Remove dipstick (A) by turning it
counterclockwise to unlock it.
5. Wipe the dipstick clean and reinsert it into the engine.
215922
MAINTENANCE AND SERVICING
5.7.1 Checking Engine Oil Level, page
5.7.5 Checking Engine Coolant Level, page
5.7.3 Checking Hydraulic Oil, page
5.7.4 Checking Tire Pressure, page
5.7.2 Fuel/Water Separator, page
Filling Fuel Tank, page 116.
3.17 Harvest Performance Tracker Display, page
Figure 5.48: Engine Oil Dipstick Location
270
270.
272.
273.
5.7.6 Hoses and Lines, page
271.
A
274.
274.
5.9.2 Cleaning
81.
Revision A