Tractor Motion Start, Gb Shifting - Belarus 1822.3 Operator's Manual

unit, on the control panel of the rear axle DL, of FDA drive, of FPTO drive (if installed). On
RLL control panel the annunciator of testing electronic systems controlling RLL, lights up,
thus indicating the workability and blocking of the RLL control system;
- after the engine is started, a LED lamp of green color lights up on the handle of
the lever shifting speeds and passes of the reduction unit; and on the control panel of the
rear axle DL, FDA drive and FPTO drive (if installed) – the annuncitor of a lower pass of
the gearbox reduction units, informing that a lower pass of the reduction unit is engaged;
- the pilot lamp of additional battery charging with 24V shall go out after the engine
is started, indicating that the additional battery is being charged with 24V through a voltage
converter. If the pilot lamp of charging stays on after the engine is started, this means, that
the additional battery is not being charged, this failure is to be eliminated.
IT IS FORBIDDEN TO OPERATE THE TRACTOR IN CLOSED ROOMS WITHOUT
A REQUIRED VENTILATION (AIR EXCHANGE). EXHAUST GASES MAY LEAD TO A
LETHAL OUTCOME!
IT IS FORBIDDEN TO RUN THE ENGINE WITH THE SYSTEMS OF COOLING
AND ENGINE LUBRICATION UNFILLED!
ATTENTION: THE TRACTOR CAB IS EQUIPPED WITH A SINGLE-OCCUPANCY
SEAT AND THE OPERATOR IS THE ONLY PERSON TO STAY IN!
ATTENTION: START THE ENGINE AND INSPECT GAUGES ONLY WHEN STAY-
ING IN THE OPERATOR'S SEAT!
ATTENTION: KEEP IN MIND THAT THE ENGINE START IS POSSIBLE ONLY
WHEN THE RANGE SHIFTING LEVER IS SET INTO A NEUTRAL POSITION!
ATTENTION: START THE ENGINE BY TOWING ONLY AT EMERGENCY SITUA-
TUIONS AND ONLY IN THE TRACTOR THAT HAS PASSED A FULL 30-HOUR RUN-IN.

4.2.3 Tractor motion start, GB shifting

ATTENTION: YOUR TRACTOR IS EQUIPPED WITH TURBOCHARGED ENGINE.
HIGH SPEED OF THE TURBOCHARGER REQUIRES GOOD LUBRICATION AT EN-
GINE START. AFTER ENGINE START WARM THE ENGINE UP TO ATTAIN A STABLE
OPERATION UNDER 700-900 RPM OF THE CRANKSHAFT (FOR 2-3 MIN), THEN LET
THE ENGINE RUN AT INCREASED RPM, GRADUALLY ADDING TO THE SPEED UP
TO 1600 RPM (NO MORE) UNTIL THE COOLANT TEMPERATURE REACHES 40°C.
TRACTOR OPERATION IS FORBIDDEN, IF THE ENGINE EMERGENCY OIL
PRESSURE LAMP IS ON WITH THE ENGINE RUNNING, STOP THE ENGINE IMMEDI-
ATELY!
167
https://tractormanualz.com/
2022.3-0000010 OM