Troubleshooting - Yamaha TDM850 1996 Service Manual

TROUBLESHOOTING

STARTER MOTOR DOES NOT OPERATE.
Procedure
Check:
1. Fuse (main and ignition)
2. Battery
3. Starter motor
4. Starting circuit cut-off relay
5. Starter relay
6. Main switch
7. Engine stop switch
NOTE:
S Remove the following parts before troubleshoot-
ing.
1) Seat
2) Side cowlings
3) Side covers
4) Fuel tank
5) Air filter case
S Use the following special tool(s) in this trouble-
shooting.
1. Fuse (main and ignition)
Refer to "SWITCH INSPECTION".
2. Battery
S Check the battery condition.
Refer to "BATTERY INSPECTION" in CHAP-
TER 3.
Open circuit voltage:
12.8 V or more at 20_C
ELECTRIC STARTING SYSTEM
CONTINUITY
CORRECT
:
8. Neutral switch
9. Sidestand switch
10. Clutch switch
11. Start switch
12. Wiring connection
(entire starting system)
Pocket tester:
90890-03112
NO CONTINUITY
Replace fuse(s).
INCORRECT
S Clean battery terminals.
S Recharge or replace the battery.
8-12
ELEC