Genie Z-45/25 Service Manual page 9

First Edition • Second Printing
Section Four Scheduled Maintenance Procedures, continued
E-1
E-2
E-3
E-4
E-5
E-6
E-7
E-8
E-9
Section Five Troubleshooting Flow Charts
Introduction ............................................................................................................... 5 - 1
Fault Codes .............................................................................................................. 5 - 3
1
2
2A
3
4
5
6
7
8
9
10
11
Part No. 52709
Test or Replace the Hydraulic Oil .................................................................. 4 - 70
Change or Recondition the Engine Coolant - Ford Models ........................... 4 - 72
Change the Fuel Hoses ................................................................................ 4 - 74
Check the Toothed Belt - Deutz Diesel Models ............................................. 4 - 77
Check the Engine Valve Clearance - Ford Models ........................................ 4 - 77
Check the Engine Cylinder Compression - Ford Models ............................... 4 - 77
Check the Fuel Injection Pumps and Injectors - Deutz Diesel Models ........... 4 - 77
Replace the Timing Belt - Ford Models ......................................................... 4 - 77
Grease the Steer Axle Wheel Bearings, 2WD Models .................................. 4 - 78
Engine Will Not Crank Over ............................................................................ 5 - 6
Engine Cranks Over But Will Not Start - Ford Models ..................................... 5 - 8
Engine Runs While Cranking Then Dies ....................................................... 5 - 10
Engine Cranks Over But Will Not Start - Diesel Models ................................ 5 - 11
Engine Will Not Start On LPG, But Will Start On Gasoline - Ford Models ..... 5 - 14
Engine Will Not Start On Gasoline, But Will Start On LPG - Ford Models ..... 5 - 16
Engine High Idle Inoperative - Ford Models .................................................. 5 - 17
Engine Low Idle Inoperative - Ford Models ................................................... 5 - 18
Engine High Idle Inoperative - Diesel Models ................................................ 5 - 19
Engine Low Idle Inoperative - Diesel Models ................................................. 5 - 21
All Functions Inoperative, Engine Starts and Runs ....................................... 5 - 22
All Lift and Steer Functions Inoperative, Drive Functions Operational ........... 5 - 23
Genie Z-45/25 & Genie Z-45/25J
TABLE OF CONTENTS
ix