Chery A11 2003 Repair Manual page 287

Maintenance Manual for Chery·Windcloud
1). Engine dose not rotate or rotates slowly when starting
Step Operation
1 Check the voltage between two terminals of
accumulator with a multimeter to see if it is around
10-12.5V.
2 Turn ignition switch to "ON". Check the voltage on
terminal of ignition switch connected to anode of
accumulator with a multimeter to see if it is around
10-12.5V.
3 Keep iginition switch at "ON", check the voltage on
terminal to ignition switch connected to starting
motor push-pull coil with a multimeter to see if it is
higher than 8V.
4 Check starting motor with a multimeter to see if open
or short circuit occurs.
5 Check engine to see if it is stuck due to poor
lubrication (turn crankshaft with tool at belt pulley
to see if it rotates).
6 In case of cold weather, check engine lubricant and
gearbox oil to see if they cause excessive resistance to
starting motor (check engine oil viscocity to see if it
is normal).
Marelli EFI System
Result Solution
Go to next step
Yes
Repair or replace
No
accumulator
Go to next step
Yes
Repair
No
or change wire
Go to next step
Yes
Repair or replace
No
ignition switch
Repair or replace
Yes
starting motor
Go to next step
No
Yes
Eliminate failure
Go to next step
No
Replace lubricant
Yes
or oil with proper
models
Check other parts
No
terminal
36