Chery A11 2003 Repair Manual page 215

1.engine does not run during starting:
Cause
correction
(1). Battery wires are loose or corroded
wires .
(2). Battery is discharged or damaged
battery .
(3). Starter circuits is opened or loosed or not energized
(4). Starter solenoid valve or switch is damaged
(5). Starter is damaged
(6). Flywheel gear ring or starter pinion is loosed or damaged
(7). No engine ground wire or ground wire is disconnected
2. engine runs but no spark exists during starting:
Cause
correction
(1). No fuel in fuel tank
(2). No fuel in the carburetor float chamber
engine
(3). Battery is discharged(engine run slowly)
(4). Battery wire connector is loosed or corroded
(5). Ignition parts is damp or damaged
(6). Ignition part harness is opened ,loosed or not energized.
(7). Spark plug is burned away, damaged or
Spark plug gap is not correct.
(8). Main mechanism is damaged(for example, camshaft)
(9). Fuel pump is damaged
(10).Carburetor float chamber needle valve is binding or
oil strainer is blocked
(11).Idle cut-off valve does not open
3. difficult to start for engine when temperature is low:
Cause
(1). Battery discharged
(2). Battery connector loosed or corroded
(3). Spark plug is corroded , damaged or the
Spark plug gap is not right.
(4). Other ignition system problem
(5). Low cylinder compression pressure
PDF 文件使用 "pdfFactory Pro" 试用版本创建
Carburetor engine faults ,causes and corrections
s
www.fineprint.com.cn
CAC Gasoline Engine Maintenance And Servicing Manual
reconnect or replace the
recharge or replace the
energize or replace the harness
replace starter solenoid valve or
switch
replace flywheel gear ring or
starter
connect or replace the ground
wire
keep
recharge or replace battery
reconnects or replace battery
replace ignition parts
Reconnect or replace harness
Replace spark plug
check and service
check, service and clean
check circuit and solenoid
correction
recharge battery
connect or replace the battery wires.
Replace spark plug
check and service
sent to service spot for check and service
replace starter
fuel the tank
trying to start
replace pump
71