Setting Up The Charging Station; Preparing Cables - Siemens SICHARGE D Operating Instructions Manual

Installation and mounting

5.5 Setting up the charging station

5.5 Setting up the charging station
NOTE
Secure and clear communication between the crane or forklift driver and the installer must
be guaranteed while the charging station is being positioned and set up.
An Installation and commissioning video (https://www.youtube.com/watch?v=W6StEHvtZLE)
is available for an overview of the most important steps. Extended version on request.
NOTE
IP protection is only guaranteed after installation of the roof (see Mounting the roof and filter
cover (Page 94)) or cable management (see Installing the cable management (Page 86)). In
any case, install one of these elements (depending on the selected configuration) before
exposing the station to outdoor weathering. Otherwise, penetrating water may damage the
device.
5.5.1

Preparing cables

Prepare all required conductors and connections before you start positioning the charging
station on the foundation.
Power supply cable
To connect the individual wires correctly, you need to prepare the individual conductors of
the power supply cable. Proceed as follows:
Observe the five safety rules according to DIN EN 50110-1:2013
Working on live parts can result in severe injuries and death. Only work on the electrical
equipment when it is in a de-energized state.
1. Shorten the cables to a length that allows you to easily introduce them into the charging
station, recommendation: 60 cm measured from the top edge of the foundation. Note the
exact position of the AC cable entry on the front of the charging station.
2. Remove the sheath from the AC cables.
3. Protect the individual conductors properly from environmental influences such as dirt and
moisture.
Network cable
You can connect the charging station to the network using an Ethernet cable. Ensure proper
protection of the cable from environmental impacts such as dirt and moisture. Note the
information on installing from the section "Base area and foundation (Page 76)".
82
WARNING
Operating Instructions, 11/2023, A5E50556539-AG
SICHARGE D