Club Car TURF 272 Maintenance Manual page 189

TROUBLESHOOTING AND ELECTRICAL SYSTEM: FE400, KEY-START ENGINE
TROUBLESHOOTING GUIDE
SYMPTOM
Starter fails to operate, continued.
Starter/Generator does not charge
battery.
Transmission does not engage or
disengage smoothly.
Troubleshooting Guide continued on next page...
2001/2002 Turf/Carryall 272 Gasoline Vehicle Maintenance and Service Manual
POSSIBLE CAUSES
Fuse is blown
Battery is dead
Starter control circuit is
not operating
Starter/generator failed
Starter solenoid failed
Key switch failed
Lockout limit switch failed
Loose or broken wire in starter/generator
circuit
Cylinder and/or crankcase flooded with
fuel
Diode failed (open condition)
Loose or broken wire in the starter/
generator circuit
Generator field coil is shorted
Brushes are worn or commutator is dirty
Starter/generator belt is loose or slipping
Voltage regulator failed
Battery failed
Transmission shifter linkage is binding or
is out of adjustment
Idle RPM Setting is set too high
Insufficient (low) level of lubricant or
wrong type of lubricant in transmission
Troubleshooting Guide
REFER TO
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 2
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 1
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Starter Circuit on page 11a-16
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 8
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 6
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 4
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 7
Starter/Generator, Section 12a,
Page 12a-2
Section 14 – Fuel System
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 10
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 11
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 11
Starter/Generator, Section 12a,
Page 12a-2
Starter/Generator, Section 12a,
Page 12a-2
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 12
Section 11a – Troubleshooting and
Electrical System: FE400, Key-Start
Engine, Test Procedure 1
Forward/Reverse Shifter Cable
Adjustment, Section 16a, Page 16a-51
Section 14 – Fuel System
Unitized Transaxle Service,
Section 16a, Page 16a-5
Page 11a-5
11A