Table of Contents
Advertisement
ATTACHMENTS / CONTROL LINKAGE
Table of Contents
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Single Cable
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dual Cable - Dual Outboard
Ride Guide Steering Cable/Attaching Kit Installation
(92876A10)
Single Cable
Refer to "Quicksilver Accessories Guide" to determine correct length of steering
cable and remote control cables.
IMPORTANT: Steering cable and remote control cables must be the correct length,
sharp bends on too-short cables result in "kinks"; too-long cables require unnec-
essary bends and/or loops. Both conditions place extra stress on the cables and
will reduce the performance of the steering system.
INSTALLING RIDE GUIDE CABLE TO OUTBOARD TILT TUBE
IMPORTANT: Before installing steering cable in tilt tube, lubricate entire cable end
with Quicksilver 2-4-C with Teflon.
NOTE: Ride Guide steering cable is lubricated at the factory and requires no additional
lubrication at initial installation.
1. Lubricate seal (a) inside of outboard tilt tube and entire cable end (b) with Quicksilver
2-4-C with Teflon.
2. Insert steering cable end thru outboard tilt tube and secure steering cable to tilt tube
with steering cable attaching nut (c), as shown. Torque nut to 35 lb. ft. (47.5 N·m).
90-883728 JULY 2001
Section 7
7-1
7-1
. . . . . . . . . . . . . . . . . . . .
7-2
7-3
. . . . . . . . . . . . . . . .
7-3
. . . . .
7-4
. . . . .
7-5
. . . . . . . . . . . . . . . . . . .
7-6
7-7
7-7
. . . . . . . . . . . . . . . . . . . .
7-9
7-10
. . . . . . . . . . . . . . . .
7-10
c
ATTACHMENTS / CONTROL LINKAGE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
b
57833
. . . . . . . . . . . . . . . . . . .
7-10
7-11
. . . . . . . . . . . . . . . . . . . .
7-18
7-25
7-25
. . . . . . . . . . . . . . . . . . .
7-26
7-28
. . . . . . . . . . . . . . . . . . . .
7-28
. . . . . . . . . . . . . . . . . . .
7-31
. . . . .
7-32
. . . . . . . . . . . . . . . . . . . . .
7-32
. . . . . . . . . . . . . . . . . . .
7-32
a
a
28160
Page 7-1
7
Advertisement
Chapters
Table of Contents
Troubleshooting
