Henny Penny 500 Service Manual page 86

Remove hardware attaching the motor to the motor base bracket and remove
8 8 ) )
motor and pump assembly.
2 2 . . 1 1 7 7 . . 9 9 F F i i l l t t e e r r P P u u m m p p M M o o t t o o r r P P r r o o t t e e c c t t o o r r - - M M a a n n u u a a l l R R e e s s e e t t
The filter pump motor is equipped with a manual reset button in the event the motor's
thermal protector actuates. This reset button is located on the rear of the motor. Wait
approximately 5 minutes before attempting to reset this protector device.
2 2 . . 1 1 8 8 E E l l e e c c t t r r i i c c a a l l C C o o n n v v e e r r s s i i o o n n s s
On occasion, it may be necessary to make electrical conversion to a fryer. Factory
conversion kits are available and should be used. The following procedures describe
these conversions.
2 2 . . 1 1 8 8 . . 1 1 P P r r o o c c e e d d u u r r e e s s
2 2 0 0 8 8 V V o o l l t t s s t t o o 2 2 2 2 0 0 / / 2 2 4 4 0 0 V V o o l l t t s s : :
The only change necessary is to remove the 208 volt heating elements and replace
them with 220/240 volt heating elements. Delay timers must be changed on variable
temperature models.
2 2 2 2 0 0 / / 2 2 4 4 0 0 V V o o l l t t s s t t o o 2 2 0 0 8 8 V V o o l l t t s s : :
The only change necessary is to remove the 220/240 volt heating elements and
replace them with 208 heating elements. Delay timers must be changed on variable
temperature models.
S S i i n n g g l l e e P P h h a a s s e e t t o o T T h h r r e e e e P P h h a a s s e e : :
A factory conversion it (Part No. 14034) is available for this conversion. This kit
includes all necessary components and a wiring diagram.
T T h h r r e e e e P P h h a a s s e e t t o o S S i i n n g g l l e e P P h h a a s s e e : :
A factory conversion kit (Part No. 14033) is available for this conversion. This kit
includes all necessary components and a wiring diagram.
Refer to the proper figure in the illustrated parts listing (Section 3), and Section 2 for
maintenance assistance for the fryer being converted to and from.
72
T T o o p p r r e e v v e e n n t t b b u u r r n n s s c c a a u u s s e e d d b b y y s s p p l l a a s s h h i i n n g g s s h h o o r r t t e e n n i i n n g g , , t t h h e e
u u n n i i t t ' ' s s m m a a i i n n p p o o w w e e r r s s w w i i t t c c h h m m u u s s t t b b e e i i n n t t h h e e o o f f f f p p o o s s i i t t i i o o n n b b e e f f o o r r e e
r r e e s s e e t t t t i i n n g g t t h h e e f f i i l l t t e e r r p p u u m m p p m m o o t t o o r r ' ' s s m m a a n n u u a a l l r r e e s s e e t t p p r r o o t t e e c c t t i i o o n n
d d e e v v i i c c e e . .