Henny Penny 500 Service Manual page 54

Reconnect wires to switch in the same position as noted on the labels.
4 4 ) )
Replace control panel per
5 5 ) )
2 2 . . 1 1 4 4 . . 5 5 I I n n d d i i c c a a t t o o r r L L i i g g h h t t s s
The indicator lights for HEAT-PUMP-POWER, are identical assemblies consisting of a
neon light and mounting clip, and are replaced as assemblies.
Remove control panel per
1 1 ) )
Disconnect indicator light wires from the individual power source.
2 2 ) )
Squeeze the retaining clip while removing the indicator light and discard the
3 3 ) )
light.
Install the new indicator light.
4 4 ) )
Connect the wires from the new indicator light.
5 5 ) )
Replace control panel per
6 6 ) )
2 2 . . 1 1 4 4 . . 6 6 F F u u s s e e H H o o l l d d e e r r
There are two fuse holders on each model of the electric fryers.
2 2 . . 1 1 4 4 . . 7 7 C C h h e e c c k k i i n n g g P P r r o o c c e e d d u u r r e e F F o o r r F F u u s s e e s s
C C O O N N T T R R O O L L P P A A N N E E L L F F U U S S E E S S 3 3 P P h h a a s s e e : :
Check from #54 to #55 and #68 to #69 on fuse assembly. The circuit should be
closed. If not, replace the fuse (HP# EF02-007).
2 2 . . 1 1 4 4 . . 8 8 C C o o r r d d & & P P l l u u g g C C h h e e c c k k
Perform a check on the cord and plug as follows:
Test from each plug prong to the corresponding wire lead on the other end of the cord
at junction box. The result should be a closed circuit on each line tested.
2 2 . . 1 1 4 4 . . 9 9 W W a a l l l l R R e e c c e e p p t t a a c c l l e e ( ( V V o o l l t t a a g g e e C C h h e e c c k k ) )
2 2 . . 1 1 4 4 . . 9 9 . . 1 1 E E l l e e c c t t r r i i c c M M o o d d e e l l s s
Check the voltage across the following lines: L1-L2; L2-L3; L1-L3.
40
2.4.1 Raise the Control , page
T T o o a a v v o o i i d d e e l l e e c c t t r r i i c c a a l l s s h h o o c c k k o o r r p p r r o o p p e e r r t t y y d d a a m m a a g g e e , , m m o o v v e e t t h h e e
p p o o w w e e r r s s w w i i t t c c h h t t o o o o f f f f a a n n d d d d i i s s c c o o n n n n e e c c t t m m a a i i n n c c i i r r c c u u i i t t b b r r e e a a k k e e r r , , o o r r
u u n n p p l l u u g g c c o o r r d d a a t t w w a a l l l l r r e e c c e e p p t t a a c c l l e e . .
2.4 Lower the Control , page
2.4.1 Raise the Control , page
T T o o a a v v o o i i d d e e l l e e c c t t r r i i c c a a l l s s h h o o c c k k o o r r p p r r o o p p e e r r t t y y d d a a m m a a g g e e , , m m o o v v e e t t h h e e
p p o o w w e e r r s s w w i i t t c c h h t t o o o o f f f f a a n n d d d d i i s s c c o o n n n n e e c c t t m m a a i i n n c c i i r r c c u u i i t t b b r r e e a a k k e e r r , , o o r r
u u n n p p l l u u g g c c o o r r d d a a t t w w a a l l l l r r e e c c e e p p t t a a c c l l e e . .
14.
14.
14.