Table of Contents
Advertisement
7-4
11 Remove the used cleaning card from the reject bin. If you perform other cleaning
12 Push down on the cover of the printer's top cover to unlatch it. Lift the top cover to
13 Replace the print ribbon cartridge. See
14 If the printer includes topcoat or overlay stations, replace the supply cartridges.
15 Close the cover of the printer and press to latch it in place.
16 Move cards back so they can be picked and release the card pusher. Replace the
17 Cycle power to the printer.
You are ready to resume normal printer operation.
Routine maintenance and cleaning
This section describes how to maintain and clean the ImageCard IV printer. Perform
routine cleaning tasks weekly or after every 5000 cards. Routine cleaning tasks
include:
•
•
The printer picks the cleaning card and automatically moves it through the printer
several times. The printer will eject the cleaning card when the cleaning cycle is
complete.
tasks now, set the card aside to use for other tasks during this cleaning session.
Discard at the end of the cleaning session.
i
Do not use the same cleaning card when you run a cleaning card in the printer
again. The cleaning card is designed to be used for one cleaning session
only.
the fully upright position.
!
When the top cover opens, the interlock switch removes power to all motors
and fans. If overlay or topcoat stations are installed, power is removed from
the heaters. Overlay or topcoat stations remain HOT.
page 4-4
for more information.
See
"Replacing the supply cartridge" on page 4-12
cartridge" on page 4-16
Lock the printer if needed.
card input tray cover.
i
If you changed the card separator setting, return the card separator to the
setting for the cards you process. See
page 3-9
for more information.
a
Press the Power button to power off the printer.
b
Press the Power button to power on the printer.
Cleaning the outside of the printer
Cleaning the inside of the printer
"Replacing the print ribbon cartridge" on
for more information.
"Printing thicker or thinner cards" on
♦
User's Guide for the ImageCard® IV Printer
Maintaining the printer
or
"Replacing the topcoat
Advertisement
Table of Contents
Troubleshooting
