Table of Contents
Advertisement
13/BRAKE SYSTEM
Checking the rear brake linings
16.9
Warning
Danger of accidents Reduced braking efficiency caused by worn brake linings.
–
Change worn brake linings immediately.
Changing the rear brake linings
16.10
Warning
Danger of accident Brake system failure.
–
Maintenance work and repairs must be carried out professionally.
Warning
Skin irritation Brake fluid can cause skin irritation on contact.
–
Avoid contact with skin and eyes, and keep out of the reach of children.
–
Wear suitable protective clothing and goggles.
–
If brake fluid comes into contact with the eyes, flush the eyes thoroughly with water and consult a physician immediately.
Warning
Danger of accidents Reduced braking efficiency due to old brake fluid.
–
Change the brake fluid of the front and rear brake according to the service schedule.
Warning
Danger of accidents Reduced braking efficiency due to oil or grease on the brake discs.
–
Always keep the brake discs free of oil and grease, and clean them with brake cleaner when necessary.
–
Tighten the bleeder screw.
–
Close shut-off valve
–
Open the bleeder screw again until no more brake fluid emerges.
Info
This prevents overfilling of the brake fluid reservoir.
–
Tighten the bleeder screw. Remove the hose of the bleeder bottle. Attach the dust
cap.
–
Disconnect the bleeding device. Remove the bleeder cover.
–
Add brake fluid to level
Guideline
Measurement of
Brake fluid DOT 4 / DOT 5.1 (
–
Position the cover with the membrane. Mount and tighten the screws.
Info
Clean up overflowed or spilt brake fluid immediately with water.
400379-10
–
Check the hand brake lever for a firm pressure point.
–
Check the brake linings for minimum thickness
Minimum thickness
»
If the minimum thickness is less than specified:
–
Change the rear brake linings. (
–
Check the brake linings for damage and cracking.
»
If damage or cracking is visible:
–
Change the rear brake linings. (
101381-10
.
4
.
A
5 mm (0.2 in)
A
p. 268)
≥ 1 mm (≥ 0.04 in)
A
p. 99)
p. 99)
.
A
99
Advertisement
Table of Contents
